User manual AYP 8228B89 PARTS-LIST

[. . . ] WASHER CHECK WITH SUPPLIER GUIDE. BELT. MID. SP STRAP. GRILL SCREW SCREW WELDNUT SCREW SPACER LT NUT STOP. OVER. CENTER BOLT Page 2 of 54 8228B89 (1998) CHASSIS AND ENCLOSURES Ref # 90 91 92 95 98 99 100 101 102 103 106 107 108 109 112 114 115 116 117 118 119 120 122 131 132 139 Part Number 11050600 156586 156286X010 105531X 140503 140871 124236X 17490628 142273 138776 109808X 110356X 110357X 60867 72140610 150300 141461 143679 19131316 73680600 19131616 161464 150195 74291006 161330 8022J Qty Description LOCKWASHER "RAIL FRAME, LH" "PLATE DASH, SLKSCR" NUT-PUSH YT BRACKET SKID CHAS ROD BYPASS CAP SCREW LT CHECK WITH SUPPLIER LOCK BYPASS BRKT SUB= 157722 HOOD LATCH T SNAP CAP LT WASHER LT ACORN NUT RB BOLT. 3/8-14X1. 25 BUMPER. ASM BRACKET. EXT. BUMP. PLUG. PLASTIC WASHER SUB= 73690600 WASHER HYT SCREW. HEX. WS. HD BKT. SPT. HOOD/PANL SCREW. 10-24X3/8. BOLT. SHOULDER. 5/16-18 PLUG-DASH T Page 3 of 54 8228B89 (1998) DECALS Page 4 of 54 8228B89 (1998) DECALS Ref # Part Number 1 2 3 4 5 6 7 8 9 10 11 13 14 15 16 17 18 23 156835 143388 151253 151255 140837 141517 145005 162548 127520 157002 4900J 142342 141587 160397 165400 151477 146615 141619 106202X 133671 138311 165610 Qty Description REFER TO IMAGE "DECAL-INST, OPER" NAMEPLATE. HD. WIZA DECAL. HD. RH. WIZRD DECAL. HD. LH. WIZRD DECAL BRAK PARK DECAL DECK WIZ + DECAL. BATRY. 3-3908 DECAL. SIDE. PANEL NLA "DECAL DANGER, FEND" DECAL T DECAL D-BAR CNTRL DECAL CHASSIS 50 SUB= 532160397 DECAL, ENGINE DECAL. GRILLE. WIZ+ DECAL. FENDER. WIZ DECAL INS STG WHL REFLECTOR-TAIL YT FOOTREST PAD DECAL HANDLE LIFT MANUAL. O. 8228B89. E Page 5 of 54 8228B89 (1998) ELECTRICAL Page 6 of 54 8228B89 (1998) ELECTRICAL Ref # 1 2 3 4 6 8 10 11 12 16 19 20 21 22 24 25 26 28 29 30 31 32 33 40 41 42 43 45 50 51 70 81 Part Number 144926 10040400 19091016 73220400 7603J 145211 150109 145769 153664 10090400 73350400 136850 4152J 4206J 146149 108824X 4207J 160784 140301 124211X 141226 122147X 160725 17720408 131563 145673 122822X 154959 140405 164767 109748X Qty Description SUB= 123899X CHECK WITH SUPPLIER LOCKWASHER WASHER SUB= 50675 "TRAY T, BATTERY" SUB= 150177 HOLDDOWN BATTERY SUB= 150177 SWITCH INTERLOCK SUB= 10040400 NUT "HARNESS, LIGHT SOC" HEADLAMP BULB CABLE-BATTERY T CABLE. 6GA. 12. 5. [. . . ] NO. 2) PUMP, OIL ROD, PUSH (STEEL) ROD, PUSH (ALUMINUM) FILTER, OIL ARM, ROCKER VALVE OVERHAUL KIT SHAFT, OIL PUMP LABEL KIT, EMISSION OWNER'S MANUAL RETAINER, BRUSH PIVOT, ROCKER ARM ENGINE Page 19 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Page 20 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 1 2 3 4 5 5A 6 7 8 9 10 11 12 13 15 16 20 22 23 24 25 25 25 25 26 26 26 26 27 28 29 32 33 34 35 40 42 45 46 50 51 51A 53 73 75 78 87 89 95 98 102 104 105 108 110 116 116A 116B Part Number 499584 499585 690926 690069 499587 499595 690097 690962 499601 690937 691003 690942 690945 690360 690946 691046 690947 690308 691053 690974 499588 499589 499590 499591 499604 499605 499606 499607 690975 499582 499583 690976 499596 499597 690963 690964 499586 690977 690978 690948 690949 690950 690951 691055 691056 691057 690657 690238 690718 499802 690234 690984 690985 690986 691261 690987 690988 690589 Qty Description CYLINDER ASSY BUSHING CYLINDER SEAL OIL SUMP ENGINE HEAD CYLINDER NO. 2 WASHER FLAT GASKET, CYLINDER HEAD BREATHER ASSY GASKET BREATHER SCREW, HEX TUBE, BREATHER GASKET, CRANKCASE SCREW, CYLINDER HEAD (3-9/16") PLUG, OIL DRAIN CRANKSHAFT SEAL OIL SCREW, CRANKCASE COVER FLYWHEEL KEY, FLYWHEEL PISTON ASSY (STD) PISTON ASSY (. 010" O. S. ) PISTON ASSY (. 020" O. S. ) PISTON ASSY (. 030" O. S. ) RING SET, PISTON (STD. ) RING SET, PISTON (. 010" O. S. ) RING SET, PISTON (. 020" O. S. ) RING SET, PISTON (. 030" O. S. ) LOCK, PISTON PIN PIN ASSY, PISTON ROD ASSY, CONNECTING SCREW, CONNECTING ROD VALVE, EXHAUST VALVE, INTAKE SPRING, VALVE RETAINER, VALVE KEEPER VALVE TAPPET, VALVE GEAR, CAM MANIFOLD, INTAKE GASKET, CARB. MOUNTING GASKET, INTAKE MANIFOLD STUD, CARB. MOUNTING SCREEN, ROTATING WASHER, SPRING SCREW, TORX SEAL, GOVERNOR SHAFT PLUG, OIL SCREW, SLOTTED SCREW, IDLE SPEED GASKET, PLATE PIN, FLOAT HINGE VALVE, NEEDLE VALVE, CHOKE WASHER O-RING, SOLENOID RETAINER O-RING, FUEL TRANSFER TUBE SEAL, O-RING (OIL PUMP COVER) Page 21 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 116C 116D 117 119 119A 119B 119C 121 122 125 130 131 133 135 137 141 142 146 150 160 163 176 187 187A 188 190 192 195 209 211 212 213 216 219 220 222 227 240 252 256 258 265 277 304 305 309 310 311 332 333 334 337 351 355 358 363 383 387 Part Number 691031 691032 690232 690990 690991 690992 690720 499811 690952 499804 690993 499805 499806 499803 690994 499807 499808 94388 281767 690996 691001 691033 691050 691049 691058 690953 690083 690018 690019 691020 691021 691022 394348 690412 691023 691048 691035 690956 690957 691003 691024 691029 691004 691005 691262 691263 691264 690059 691060 691061 691043 691044 690997 499889 691062 690966 691034 Qty Description SEAL, O-RING (DIPSTICK) SEAL, O-RING (OIL FILTER TUBE) JET, MAIN (STANDARD) SCREW, PHILLIPS SCREW, PHILLIPS SCREW, PHILLIPS SCREW, PHILLIPS CARBURETOR OVERHAUL KIT SPACER, CARBURETOR CARBURETOR VALVE, THROTTLE SHAFT, THROTTLE FLOAT, CARBURETOR TUBE, FUEL TRANSFER GASKET, FLOAT BOWL SHAFT CHOKE NOZZLE, CARBURETOR TIMING GEAR KEY GASKET, NOZZLE RETAINER, SOLENOID GASKET, AIR CLEANER SCREW, T-30 LINE, FUEL LINE, FUEL SCREW, HEX SCREW, TORX HEX ADJUSTER, ROCKER ARM CHECK WITH SUPPLIER SPRING, GOVERNOR SPRING, GOVERNED IDLE LINK, THROTTLE BRACKET, CHOKE CONTROL LINK, CHOKE GEAR, GOVERNOR WASHER, THRUST PLATE, GOVERNOR CONTROL LEVER ASSY, GOVERNOR FILTER, FUEL ELEMENT, BREATHER RETAINER, ELEMENT SCREW, HEX CLAMP, CASING NUT, HEX HOUSING, BLOWER SCREW, HEX MOTOR, STARTER SCREW, HEX BRUSH, SET NUT, FLYWHEEL ARMATURE, MAGNETO SCREW, ARMATURE MOUNTING SPARK PLUG SCREW, HEX WASHER, SEAL GASKET SET FLYWHEEL, PULLER WRENCH, SPARK PLUG PUMP, FUEL Page 22 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 445 467 474 482 510 523 525 552 552A 556 562 573 592 592A 601 615 615A 615B 616 633 634 635 668 703 718 726 728 741 783 788 789 801 802 823 847 851 855 865 865A 865B 868 871 878 881 883 918 947 965 967 968 975 977 987 1005 1006 1017 1019 1022 Part Number 691007 691008 691063 691183 497606 691036 691037 690552 690553 690967 690311 691009 690958 691029 691038 690328 690317 691265 691045 690998 690442 691210 691215 690010 690959 499612 690372 690980 691280 691039 691220 691283 691286 690960 499602 691234 691011 691012 691013 691015 690968 690969 691237 690999 690970 691040 499809 499613 691016 499788 499810 499812 691000 691243 691247 690770 690103 690971 Qty Description CARTRIDGE, AIR CLEANER NUT, AIR CLEANER ALTERNATOR SCREW, HEX DRIVE, STARTER DIPSTICK, OIL TUBE, OIL FILL BUSHING, GOVERNOR CRANK BUSHING, GOVERNOR CRANK SCREW, HEX BOLT, CARRIAGE PLATE, BLACK NUT, HEX NUT, HEX CLAMP, FUEL LINE RETAINER, GOVERNOR RETAINER, GOVERNOR RETAINER CRANK, GOVERNOR SEAL, CHOKE SHAFT WASHER, FLAT BOOT, SPARK PLUG SPACER CLIP, HOSE DOWEL, SLEEVE GEAR, RING SCREW, TORX GEAR, TIMING GEAR, STARTER BRACKET, PUMP HARNESS, WIRING CAP, DRIVE CAP, END SCREW, HEX DIPSTICK/TUBE ASSY TERMINAL, IGNITION CABLE ADAPTER, AIR COVER, AIR GUIDE COVER, AIR GUIDE COVER, AIR GUIDE SEAL, VALVE BUSHING, GUIDE WIRE, ALTERNATOR PLATE, COVER GASKET, EXHAUST HOSE, VACUUM SOLENOID, FUEL COVER, OIL PUMP FILTER, PRE-CLEANER COVER, AIR CLEANER BOWL, FLOAT GASKET SET, CARBURETOR SEAL, THROTTLE SHAFT FAN, FLYWHEEL RETAINER, FAN SCREEN, OIL PUMP LABEL KIT GASKET, ROCKER COVER Page 23 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 1023 1023A 1024 1026 1026A 1027 1029 1033 1035 1036 1058 1090 1100 2500 Part Number 499599 499600 499054 690981 690982 690041 690972 499890 691042 499783 273694 691293 690973 407777-0027 Qty Description COVER, ROCKER (CYL. NO. 2) PUMP, OIL ROD, PUSH (STEEL) ROD, PUSH (ALUMINUM) FILTER, OIL ARM, ROCKER VALVE OVERHAUL KIT SHAFT, OIL PUMP LABEL KIT, EMISSION OWNER'S MANUAL RETAINER, BRUSH PIVOT, ROCKER ARM ENGINE Page 24 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Page 25 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 1 2 3 4 5 5A 6 7 8 9 10 11 12 13 15 16 20 22 23 24 25 25 25 25 26 26 26 26 27 28 29 32 33 34 35 40 42 45 46 50 51 51A 53 73 75 78 87 89 95 98 102 104 105 108 110 116 116A 116B Part Number 499584 499585 690926 690069 499587 499595 690097 690962 499601 690937 691003 690942 690945 690360 690946 691046 690947 690308 691053 690974 499588 499589 499590 499591 499604 499605 499606 499607 690975 499582 499583 690976 499596 499597 690963 690964 499586 690977 690978 690948 690949 690950 690951 691055 691056 691057 690657 690238 690718 499802 690234 690984 690985 690986 691261 690987 690988 690589 Qty Description CYLINDER ASSY BUSHING CYLINDER SEAL OIL SUMP ENGINE HEAD CYLINDER NO. 2 WASHER FLAT GASKET, CYLINDER HEAD BREATHER ASSY GASKET BREATHER SCREW, HEX TUBE, BREATHER GASKET, CRANKCASE SCREW, CYLINDER HEAD (3-9/16") PLUG, OIL DRAIN CRANKSHAFT SEAL OIL SCREW, CRANKCASE COVER FLYWHEEL KEY, FLYWHEEL PISTON ASSY (STD) PISTON ASSY (. 010" O. S. ) PISTON ASSY (. 020" O. S. ) PISTON ASSY (. 030" O. S. ) RING SET, PISTON (STD. ) RING SET, PISTON (. 010" O. S. ) RING SET, PISTON (. 020" O. S. ) RING SET, PISTON (. 030" O. S. ) LOCK, PISTON PIN PIN ASSY, PISTON ROD ASSY, CONNECTING SCREW, CONNECTING ROD VALVE, EXHAUST VALVE, INTAKE SPRING, VALVE RETAINER, VALVE KEEPER VALVE TAPPET, VALVE GEAR, CAM MANIFOLD, INTAKE GASKET, CARB. MOUNTING GASKET, INTAKE MANIFOLD STUD, CARB. MOUNTING SCREEN, ROTATING WASHER, SPRING SCREW, TORX SEAL, GOVERNOR SHAFT PLUG, OIL SCREW, SLOTTED SCREW, IDLE SPEED GASKET, PLATE PIN, FLOAT HINGE VALVE, NEEDLE VALVE, CHOKE WASHER O-RING, SOLENOID RETAINER O-RING, FUEL TRANSFER TUBE SEAL, O-RING (OIL PUMP COVER) Page 26 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 116C 116D 117 119 119A 119B 119C 121 122 125 130 131 133 135 137 141 142 146 150 160 163 176 187 187A 188 190 192 195 209 211 212 213 216 219 220 222 227 240 252 256 258 265 277 304 305 309 310 311 332 333 334 337 351 355 358 363 383 387 Part Number 691031 691032 690232 690990 690991 690992 690720 499811 690952 499804 690993 499805 499806 499803 690994 499807 499808 94388 281767 690996 691001 691033 691050 691049 691058 690953 690083 690018 690019 691020 691021 691022 394348 690412 691023 691048 691035 690956 690957 691003 691024 691029 691004 691005 691262 691263 691264 690059 691060 691061 691043 691044 690997 499889 691062 690966 691034 Qty Description SEAL, O-RING (DIPSTICK) SEAL, O-RING (OIL FILTER TUBE) JET, MAIN (STANDARD) SCREW, PHILLIPS SCREW, PHILLIPS SCREW, PHILLIPS SCREW, PHILLIPS CARBURETOR OVERHAUL KIT SPACER, CARBURETOR CARBURETOR VALVE, THROTTLE SHAFT, THROTTLE FLOAT, CARBURETOR TUBE, FUEL TRANSFER GASKET, FLOAT BOWL SHAFT CHOKE NOZZLE, CARBURETOR TIMING GEAR KEY GASKET, NOZZLE RETAINER, SOLENOID GASKET, AIR CLEANER SCREW, T-30 LINE, FUEL LINE, FUEL SCREW, HEX SCREW, TORX HEX ADJUSTER, ROCKER ARM CHECK WITH SUPPLIER SPRING, GOVERNOR SPRING, GOVERNED IDLE LINK, THROTTLE BRACKET, CHOKE CONTROL LINK, CHOKE GEAR, GOVERNOR WASHER, THRUST PLATE, GOVERNOR CONTROL LEVER ASSY, GOVERNOR FILTER, FUEL ELEMENT, BREATHER RETAINER, ELEMENT SCREW, HEX CLAMP, CASING NUT, HEX HOUSING, BLOWER SCREW, HEX MOTOR, STARTER SCREW, HEX BRUSH, SET NUT, FLYWHEEL ARMATURE, MAGNETO SCREW, ARMATURE MOUNTING SPARK PLUG SCREW, HEX WASHER, SEAL GASKET SET FLYWHEEL, PULLER WRENCH, SPARK PLUG PUMP, FUEL Page 27 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 445 467 474 482 510 523 525 552 552A 556 562 573 592 592A 601 615 615A 615B 616 633 634 635 668 703 718 726 728 741 783 788 789 801 802 823 847 851 855 865 865A 865B 868 871 878 881 883 918 947 965 967 968 975 977 987 1005 1006 1017 1019 1022 Part Number 691007 691008 691063 691183 497606 691036 691037 690552 690553 690967 690311 691009 690958 691029 691038 690328 690317 691265 691045 690998 690442 691210 691215 690010 690959 499612 690372 690980 691280 691039 691220 691283 691286 690960 499602 691234 691011 691012 691013 691015 690968 690969 691237 690999 690970 691040 499809 499613 691016 499788 499810 499812 691000 691243 691247 690770 690103 690971 Qty Description CARTRIDGE, AIR CLEANER NUT, AIR CLEANER ALTERNATOR SCREW, HEX DRIVE, STARTER DIPSTICK, OIL TUBE, OIL FILL BUSHING, GOVERNOR CRANK BUSHING, GOVERNOR CRANK SCREW, HEX BOLT, CARRIAGE PLATE, BLACK NUT, HEX NUT, HEX CLAMP, FUEL LINE RETAINER, GOVERNOR RETAINER, GOVERNOR RETAINER CRANK, GOVERNOR SEAL, CHOKE SHAFT WASHER, FLAT BOOT, SPARK PLUG SPACER CLIP, HOSE DOWEL, SLEEVE GEAR, RING SCREW, TORX GEAR, TIMING GEAR, STARTER BRACKET, PUMP HARNESS, WIRING CAP, DRIVE CAP, END SCREW, HEX DIPSTICK/TUBE ASSY TERMINAL, IGNITION CABLE ADAPTER, AIR COVER, AIR GUIDE COVER, AIR GUIDE COVER, AIR GUIDE SEAL, VALVE BUSHING, GUIDE WIRE, ALTERNATOR PLATE, COVER GASKET, EXHAUST HOSE, VACUUM SOLENOID, FUEL COVER, OIL PUMP FILTER, PRE-CLEANER COVER, AIR CLEANER BOWL, FLOAT GASKET SET, CARBURETOR SEAL, THROTTLE SHAFT FAN, FLYWHEEL RETAINER, FAN SCREEN, OIL PUMP LABEL KIT GASKET, ROCKER COVER Page 28 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 1023 1023A 1024 1026 1026A 1027 1029 1033 1035 1036 1058 1090 1100 2500 Part Number 499599 499600 499054 690981 690982 690041 690972 499890 691042 499783 273694 691293 690973 407777-0027 Qty Description COVER, ROCKER (CYL. NO. 2) PUMP, OIL ROD, PUSH (STEEL) ROD, PUSH (ALUMINUM) FILTER, OIL ARM, ROCKER VALVE OVERHAUL KIT SHAFT, OIL PUMP LABEL KIT, EMISSION OWNER'S MANUAL RETAINER, BRUSH PIVOT, ROCKER ARM ENGINE Page 29 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Page 30 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 1 2 3 4 5 5A 6 7 8 9 10 11 12 13 15 16 20 22 23 24 25 25 25 25 26 26 26 26 27 28 29 32 33 34 35 40 42 45 46 50 51 51A 53 73 75 78 87 89 95 98 102 104 105 108 110 116 116A 116B Part Number 499584 499585 690926 690069 499587 499595 690097 690962 499601 690937 691003 690942 690945 690360 690946 691046 690947 690308 691053 690974 499588 499589 499590 499591 499604 499605 499606 499607 690975 499582 499583 690976 499596 499597 690963 690964 499586 690977 690978 690948 690949 690950 690951 691055 691056 691057 690657 690238 690718 499802 690234 690984 690985 690986 691261 690987 690988 690589 Qty Description CYLINDER ASSY BUSHING CYLINDER SEAL OIL SUMP ENGINE HEAD CYLINDER NO. 2 WASHER FLAT GASKET, CYLINDER HEAD BREATHER ASSY GASKET BREATHER SCREW, HEX TUBE, BREATHER GASKET, CRANKCASE SCREW, CYLINDER HEAD (3-9/16") PLUG, OIL DRAIN CRANKSHAFT SEAL OIL SCREW, CRANKCASE COVER FLYWHEEL KEY, FLYWHEEL PISTON ASSY (STD) PISTON ASSY (. 010" O. S. ) PISTON ASSY (. 020" O. S. ) PISTON ASSY (. 030" O. S. ) RING SET, PISTON (STD. ) RING SET, PISTON (. 010" O. S. ) RING SET, PISTON (. 020" O. S. ) RING SET, PISTON (. 030" O. S. ) LOCK, PISTON PIN PIN ASSY, PISTON ROD ASSY, CONNECTING SCREW, CONNECTING ROD VALVE, EXHAUST VALVE, INTAKE SPRING, VALVE RETAINER, VALVE KEEPER VALVE TAPPET, VALVE GEAR, CAM MANIFOLD, INTAKE GASKET, CARB. MOUNTING GASKET, INTAKE MANIFOLD STUD, CARB. MOUNTING SCREEN, ROTATING WASHER, SPRING SCREW, TORX SEAL, GOVERNOR SHAFT PLUG, OIL SCREW, SLOTTED SCREW, IDLE SPEED GASKET, PLATE PIN, FLOAT HINGE VALVE, NEEDLE VALVE, CHOKE WASHER O-RING, SOLENOID RETAINER O-RING, FUEL TRANSFER TUBE SEAL, O-RING (OIL PUMP COVER) Page 31 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 116C 116D 117 119 119A 119B 119C 121 122 125 130 131 133 135 137 141 142 146 150 160 163 176 187 187A 188 190 192 195 209 211 212 213 216 219 220 222 227 240 252 256 258 265 277 304 305 309 310 311 332 333 334 337 351 355 358 363 383 387 Part Number 691031 691032 690232 690990 690991 690992 690720 499811 690952 499804 690993 499805 499806 499803 690994 499807 499808 94388 281767 690996 691001 691033 691050 691049 691058 690953 690083 690018 690019 691020 691021 691022 394348 690412 691023 691048 691035 690956 690957 691003 691024 691029 691004 691005 691262 691263 691264 690059 691060 691061 691043 691044 690997 499889 691062 690966 691034 Qty Description SEAL, O-RING (DIPSTICK) SEAL, O-RING (OIL FILTER TUBE) JET, MAIN (STANDARD) SCREW, PHILLIPS SCREW, PHILLIPS SCREW, PHILLIPS SCREW, PHILLIPS CARBURETOR OVERHAUL KIT SPACER, CARBURETOR CARBURETOR VALVE, THROTTLE SHAFT, THROTTLE FLOAT, CARBURETOR TUBE, FUEL TRANSFER GASKET, FLOAT BOWL SHAFT CHOKE NOZZLE, CARBURETOR TIMING GEAR KEY GASKET, NOZZLE RETAINER, SOLENOID GASKET, AIR CLEANER SCREW, T-30 LINE, FUEL LINE, FUEL SCREW, HEX SCREW, TORX HEX ADJUSTER, ROCKER ARM CHECK WITH SUPPLIER SPRING, GOVERNOR SPRING, GOVERNED IDLE LINK, THROTTLE BRACKET, CHOKE CONTROL LINK, CHOKE GEAR, GOVERNOR WASHER, THRUST PLATE, GOVERNOR CONTROL LEVER ASSY, GOVERNOR FILTER, FUEL ELEMENT, BREATHER RETAINER, ELEMENT SCREW, HEX CLAMP, CASING NUT, HEX HOUSING, BLOWER SCREW, HEX MOTOR, STARTER SCREW, HEX BRUSH, SET NUT, FLYWHEEL ARMATURE, MAGNETO SCREW, ARMATURE MOUNTING SPARK PLUG SCREW, HEX WASHER, SEAL GASKET SET FLYWHEEL, PULLER WRENCH, SPARK PLUG PUMP, FUEL Page 32 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 445 467 474 482 510 523 525 552 552A 556 562 573 592 592A 601 615 615A 615B 616 633 634 635 668 703 718 726 728 741 783 788 789 801 802 823 847 851 855 865 865A 865B 868 871 878 881 883 918 947 965 967 968 975 977 987 1005 1006 1017 1019 1022 Part Number 691007 691008 691063 691183 497606 691036 691037 690552 690553 690967 690311 691009 690958 691029 691038 690328 690317 691265 691045 690998 690442 691210 691215 690010 690959 499612 690372 690980 691280 691039 691220 691283 691286 690960 499602 691234 691011 691012 691013 691015 690968 690969 691237 690999 690970 691040 499809 499613 691016 499788 499810 499812 691000 691243 691247 690770 690103 690971 Qty Description CARTRIDGE, AIR CLEANER NUT, AIR CLEANER ALTERNATOR SCREW, HEX DRIVE, STARTER DIPSTICK, OIL TUBE, OIL FILL BUSHING, GOVERNOR CRANK BUSHING, GOVERNOR CRANK SCREW, HEX BOLT, CARRIAGE PLATE, BLACK NUT, HEX NUT, HEX CLAMP, FUEL LINE RETAINER, GOVERNOR RETAINER, GOVERNOR RETAINER CRANK, GOVERNOR SEAL, CHOKE SHAFT WASHER, FLAT BOOT, SPARK PLUG SPACER CLIP, HOSE DOWEL, SLEEVE GEAR, RING SCREW, TORX GEAR, TIMING GEAR, STARTER BRACKET, PUMP HARNESS, WIRING CAP, DRIVE CAP, END SCREW, HEX DIPSTICK/TUBE ASSY TERMINAL, IGNITION CABLE ADAPTER, AIR COVER, AIR GUIDE COVER, AIR GUIDE COVER, AIR GUIDE SEAL, VALVE BUSHING, GUIDE WIRE, ALTERNATOR PLATE, COVER GASKET, EXHAUST HOSE, VACUUM SOLENOID, FUEL COVER, OIL PUMP FILTER, PRE-CLEANER COVER, AIR CLEANER BOWL, FLOAT GASKET SET, CARBURETOR SEAL, THROTTLE SHAFT FAN, FLYWHEEL RETAINER, FAN SCREEN, OIL PUMP LABEL KIT GASKET, ROCKER COVER Page 33 of 54 8228B89 (1998) ENGINE BRIGGS AND STRATTON Ref # 1023 1023A 1024 1026 1026A 1027 1029 1033 1035 1036 1058 1090 1100 2500 Part Number 499599 499600 499054 690981 690982 690041 690972 499890 691042 499783 273694 691293 690973 407777-0027 Qty Description COVER, ROCKER (CYL. NO. 2) PUMP, OIL ROD, PUSH (STEEL) ROD, PUSH (ALUMINUM) FILTER, OIL ARM, ROCKER VALVE OVERHAUL KIT SHAFT, OIL PUMP LABEL KIT, EMISSION OWNER'S MANUAL RETAINER, BRUSH PIVOT, ROCKER ARM ENGINE Page 34 of 54 8228B89 (1998) GROUND DRIVE Page 35 of 54 8228B89 (1998) GROUND DRIVE Ref # 2 3 5 6 7 9 15 17 20 22 23 28 29 30 33 34 35 36 37 38 39 40 41 42 46 47 48 50 51 52 53 54 55 56 58 61 64 65 66 67 68 69 70 71 72 73 74 76 77 79 80 81 82 83 84 85 86 87 Part Number 7070E 7563R 73680600 76020412 140507 140080 19131316 140921 73940800 156103 121274X 73350600 140494 19131616 12000053 124236X 137648 149412 150035 74321016 5304J 73661000 8883R 145170 138228 72110612 131494 73800600 139123 207J 161590 105706X 140218 74760724 140488 154752 67609 140296 19131312 5142H 123800X 151146 151179 73680500 74490548 142432 140481 74760716 72110505 140484 17490612 150586 140479 140490 17541020 140462 140491 Qty Description KEY 1/4 X 2. 5 WASHER T SUB= 73690600 COTTER PIN HUB WHEEL ASM BOLT. HUB. WHL. REAR WASHER SPRING ROD BRAKE SUB= 73360800 ARM ASM SHIFT KNOB. DUCKHEAD. 1/2 NUT ROD BRAKE WASHER HYT E RING HYT CAP ROD BRAKE PART GT SPRING. GRND. DRIVE CHECK WITH SUPPLIER BUSHING. NYLINER SCREW ACT-SWITCH T NUT. FLANGE PEDAL COVER T RETAINER. SPRING ROD. CLUTCH BOLT. 3/8-16X1. 50 FLAT IDLER PULLEY NUT PULLEY. IDLER. V. GR WASHER T CLUTCH. ARM. ASM "LY, BEARING" BELT-V 84. 5 BOLT PULLEY TRANSAXLE SHAFT-BRAKE/CLUTC AXLE BOLT WASHER. HARD. BLADE WASHER ROLL PIN STD WASHER SUB= 164892 "PLATE CONSOLE, SFT" SUB= 73690500 BOLT. HEX. FLGHD. SCREW HEXWSH H-L BRACKET TRAN VGTH BOLT BOLT BRACKET TORQUE RH SCREW BRACKET. MTG. FAN STRAP TORQUE MID SPACER SCREW YTV "FAN 7"" HYDRO" ADAPTER FAN Page 36 of 54 8228B89 (1998) GROUND DRIVE Ref # 88 89 90 91 92 93 94 96 98 99 100 101 104 105 106 107 108 109 111 112 113 115 116 117 Part Number 161592 73680700 140489 17490644 74760520 140502 133835 141103 141004 17490624 126881X 156106 140480 17580408 142918 154739 142917 140929 156240 156104 73220700 123405X 73900500 73900600 163198 Qty Description PULLEY FAN NUT GTV KEEPER BELT SCREW. HXWSH. 3/8 BOLT LINK ASM SHIFT XMAS TREE FASTNER WASHER NICKEL PLT BRACKET SHIFT SCREW LT WASHER COMPRESSIN WASHER-BELLVILLE BRACKET IDLER SCREW CRT O-RING. ASM. 70110 "LINE FUEL, HYD 15""" CAP. VENT. 70109 SPRING BRAKE "SPACER-LEVER, SHIF" "WASHER-NYLON, HIGH" NUT "KEEPER, DRIVE BELT" "NUT HEX, LOCK, FLAN" SUB= 83923 TRANSAXLE. HYDRO Page 37 of 54 8228B89 (1998) LIFT ASSEMBLY Page 38 of 54 8228B89 (1998) LIFT ASSEMBLY Ref # 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 29 30 31 32 33 34 35 38 39 40 41 42 43 70 72 Part Number 121006X 159187 159189 12000022 19292016 74780624 125631X 122365X 122364X 2876H 146704 163552 139868 140302 73680600 674A247 73350600 143363 19131316 5328J 74760616 127218 4939M 73350800 130171 73800800 150233 110807X 19131016 137150 76020308 137167 138057 155097 123935X 17490512 73540600 19112410 123934X 145212 Qty Description LEVER ROD LT SHAFT. ASM. LIFT. VGT LEVER. ASM. LIFT. RH E-RING WASHER "BOLT, HEX" GRIP HANDLE SUB= 125925X SUB= 125925X SPRING T LINK. LIFT. MWR. VGT RETAINER SPRING ARM SUSP REAR BEARING PVT LH SUB= 73690600 SUB= 918674A247 NUT BRACKET SPRING AS WASHER BOLT-ADJ SPRING T BOLT LINK. FRONT SUB= 85902 NUT TRUNION NUT. LK. W/WSH. 1/2. [. . . ] 0RING. 90041011340 KIT. CHARG. 2513027 GEROTOR. J1041008 SCREW. CAP. 50095. PUMP. BDU-10L-122 Page 44 of 54 8228B89 (1998) SCHEMATIC Page 45 of 54 8228B89 (1998) SCHEMATIC Ref # Part Number Qty Description REFER TO IMAGE Page 46 of 54 8228B89 (1998) SEAT ASSEMBLY Page 47 of 54 8228B89 (1998) SEAT ASSEMBLY Ref # 1 2 3 4 5 6 7 8 10 12 13 14 15 16 17 18 19 20 21 22 Part Number 127440 140551 140675 127018X 145006 73800600 124181X 150176 155925 121246X 121248X 72050412 121249X 123740X 123976X 19171912 120068X 124238X 153236 73680500 Qty Description SUB= 140121 BRACKET PVT SEAT STRAP ASM FENDER "BOLT, SHOULDER" CLIP. PUSH-IN. HING NUT SPRING COMPRESSIO BOLT. 5/16-18. UNC PAN-SEAT BRKT SWITCH BUSHING BOLT-RD HD SQ NK SPACER SPLIT SPRING COMPRESSED SUB= 73900400 WASHER "KNOB 1/2"" YT" CAP SPRING "BOLT, SHOULDER" SUB= 73690500 Page 48 of 54 8228B89 (1998) STEERING ASSEMBLY Page 49 of 54 8228B89 (1998) STEERING ASSEMBLY Ref # 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 Part Number 121472X 137094 6855M 161849 161848 6266H 121748X 12000029 121232X 74781044 136518 73901000 121749X 10040600 7810H 145103 137347 137155 156011 100711L 155105 152927 19133808 74780616 126805X 3366R 17490612 104239X 12000034 138136 19111610 10040500 74760512 138059 137156 73360600 109850X 73700600 109851X 155246 Qty Description SUB= 150546 SUB= 532137094 ZERK M SPINDLE ASM LH SPINDLE ASM RH WASHER . T WASHER RING CAP BOLT SPACER BEARING "NUT-LOC, FLANGE LT" WASHER LOCKWASHER GRIPCO NUT SHAFT. STEER. VGT ROD. ASM. TIE. BALL DRAGLINK. BALL. JOI SUPPORT ASM-STEER ADAPTER LT "BUSHING, STEERING" "SCREW-TT, 10-32 FL" WASHER T BOLT "INSERT, STR WHEEL" COL. SCREW "FLANGE GT, BEAR. " KLIP RING BUSHING. NYLINER. [. . . ]