User manual COBRA CPI 150 BK

[. . . ] As a rough guide, divide the wattage of the test load by 10 to get the current (in amperes) that the power source must supply. A fully charged standard automotive battery will work fine. 2 CPI150BK_manual. qx 4/10/06 2:09 PM Page 4 2 QUICK CHECKOUT The location where you should use your CPI 150 must be: Airplane Plug OPERATION Quick Checkout (continued) 3 To connect your inverter to the power source: 1. If the power source is a DC power supply, switch it off. CAUTION The inverter must only be connected to batteries with a nominal output voltage of 12 volts. It will not work with a 6 volt battery, and will be damaged if it is connected to a 16 volt battery. Note: Some airplanes are equipped with cigarette lighter type socket. [. . . ] This helps protect the unit from damage due to excessive input voltage. Although the inverter is protected in this way, it may still be damaged should the input voltage exceed 16 volts. Cigarette Lighter Plug power/fault indicator Airplane Plug CAUTION NOTE: Make sure you unplug inverter from power source before you leave your vehicle. Input Voltage Your CPI 150 will operate from input voltage ranging from 10 to 15 volts. Optimum performance occurs when the voltage is between 12 and 14 volts. Automatic Shutdown The unit will automatically go into thermal shutdown if it becomes overheated due to excessive input voltage, poor circulation or high ambient temperature. 6 5 CPI150BK_manual. qx 4/10/06 2:09 PM Page 8 6 TROUBLESHOOTING GUIDE MAINTENANCE & SERVICE Maintaining Your Inverter Possible Causes Solution Problem/ Symptom Low output voltage No output voltage Overload Low input voltage Short circuit or wiring error Reduce the load. Check AC wiring for short circuit or improper polarity. Make sure the inverter is connected to a 12 volt battery. Check regulation of charging system. Your CPI 150 requires very little maintenance to keep it operating properly. The exterior of the unit should be cleaned periodically with a damp cloth to prevent accumulation of dust and dirt. Keep vents and fans free from dust or debris. · Customer Service Operators are available at 773-889-3087 Monday through Friday, 8:00 a. m. · Questions can be faxed to 773-622-2269. · Automated Technical Assistance is available 24 hours, 7 days a week via e-mail at: productinfo@cobra. com. · On-line answers to frequently asked questions can be found at: www. cobra. com Cobra®, Nothing Comes Close to a Cobra® and the snake design are registered trademarks of Cobra Electronics Corporation, USA. 7 No output voltage and "fault" indicator is lit High input voltage Service You can receive technical assistance with your unit through one of our customer support services: · Automated Help Desk is available 24 hours a day, 7 days a week at 773-889-3087. No output voltage when load is in excess of 150 watts or 1. 3 amperes Thermal shutdown Allow inverter to cool down Improve ventilation-- make sure ventilation openings in the inverter are not obstructed. Lower ambient temperature. WARNING: This product contains lead, a chemical known to the State of California to cause cancer and birth defects or other reproductive harm. Wash hands after handling. 7 8 CPI150BK_manual. qx 4/10/06 2:09 PM Page 10 7 MAINTENANCE & SERVICE 4. Pack the unit securely to prevent damage during transit. If possible, use the original packing materials. Ship prepaid and insured using a traceable carrier such as United Parcel Service (UPS), Federal Express, or first class mail with delivery confirmation. Ship to: Cobra® Factory Service, Cobra Electronics Corporation, 6500 West Cortland Street, Chicago, IL 60707 USA 6. Please allow 3-4 weeks before contacting us about the status of your service. If your unity is under warranty, it will either be repaired or replaced upon receipt, depending on the model. If your unit is out of warranty, you will receive a letter informing you of the repair or replacement charge. [. . . ] · Automated Technical Assistance is available 24 hrs. , 7 days a week via e-mail at: productinfo@cobra. com. · On-line answers to frequently asked questions can be found at: www. cobra. com For additional Customer Service information, see page 8-9. LIMITED 1-YEAR WARRANTY Cobra Electronics Corporation 6500 West Cortland Street Chicago, Illinois 60707 USA 10 Congratulations Thank you for purchasing the CPI 150 BK Power Inverter . from Cobra® When used properly, your unit will give you many years of reliable service. The operating features of your CPI 150 BK include: · USB 5V Output · AC receptacle · Automatic thermal protection/shutdown 5V USB Outlet 13V Input Connector · Reverse polarity protection · Low battery shutdown 20 Amp Fuse AC Receptacle Power Cord A2 15 Amp In-Line Fuse cigarette lighter plug Cobra Electronics Corporation warrants that its Cobra® Power Inverter, and the component parts thereof, will be free of defects in material and workmanship for a period of one (1) year from the date of consumer purchase. [. . . ]