User manual COLEMAN 9992-646

[. . . ] Gas Barbecue Use, Care & Assembly Manual With Grill Lighting Instructions 7700 LP Gas Series ASSEMBLER/INSTALLER: Leave these instructions with the consumer. CONSUMER/USER: Read all instructions and keep in a safe place for future reference. www. coleman. com For Outdoor Use Only IMPORTANT Read this manual carefully before assembling, using or servicing this grill. If you have questions about assembly, operation, servicing or repair of this grill, please call Coleman at 1-800-835-3278 or TDD: 316-832-8707. In Canada call 1-800-387-6161. CERTIFIED ® ® Contents General Safety Information . 4 Fuel Connections Other Than Portable L. P. [. . . ] Gas Cylinders Leak Testing (cont. ) How to Check for Leaks 1. Make a soapy solution of equal parts mild liquid dishwashing detergent and water. Turn cylinder valve knob counterclockwise (right to left) one rotation. Apply soap solution to connections indicated with arrows in Fig. If bubbles appear at these areas, a leak is indicated. WARNING This procedure MUST be performed OUTDOORS only!Read and follow directions on the cylinder and fuel hose safety tags. CAUTION In the connection process, the grill side of the connection will seal on the back-check in the valve, resulting in a slight resistance. The connection requires about one-half to three-quarters additional turn to complete the connection. DO NOT use tools. 16 15 Fixing A Fuel Leak 1. Check that the cylinder valve is closed by turning the cylinder knob clockwise to a full stop. Check that all the grill burner knobs are in the off position. Remove the protective caps from the cylinder valve and cou pling nut. NOTE: The coupling nut connects to the large outside threads on the valve outlet. Hold the regulator in one hand and insert the nipple into the valve outlet. Be sure the nipple is centered in the valve outlet. Hand-tighten the coupling nut, taking care not to cross-thread the connection (see Fig. Turn the coupling nut clockwise, tighten to a full stop. If you cannot complete the final connection, disconnect the regulator and repeat steps 4 through 6. If you are still unable to complete the connection, DO NOT use this valve and regulator!Check that the hose has no kinks or sharp bends and clears areas that will become hot during use. Never put strain on the hose where it joins a fitting. BEFORE lighting grill, check all connections for leaks using the procedure as shown in Fig. Push in and turn on control knobs to release pressure in hose, then turn the control knobs back to off. [. . . ] ("Coleman") warrants that this product will be free from defects in material and workmanship. This warranty applies to the following parts for the following time periods: the castings are warranted for Limited Lifetime against burnthrough; the burner is warranted for Limited Lifetime; electronic ignition components are warranted for ten (10) years; cooking surfaces and other parts are warranted for five (5) years, except the propane cylinder and paint finish. We DO NOT WARRANT in any way the propane cylinder (see label on cylinder for cylinder manufacturer's warranty) or the paint finish of the product. Coleman, at its option, will repair or replace this product or any component of the product found to be defective during the warranty period. [. . . ]