User manual DAELIM DAYSTAR FI VL 125L

[. . . ] OWNER S MANUAL IMPORTANT NOTICE WELCOME Thank you for purchasing an Daelim vehicle. OPERATOR AND PASSENGER This motorcycle is designed to carry the operator and one passenger. WARNING Attempting to change the pre-set maximum speed may cause danger and will void the Daelim warranty. ON-ROAD USE This motorcycle is designed to be used only on the road. READ THIS OWNER'S MANUAL CAREFULLY Pay special attention to statements preceded by the following words: WARNING Indicates a strong possibility of severe personal injury or death if instructions are not followed. CAUTION Indicates a possibility of personal injury or equipment damage if instructions are not followed. NOTE Gives helpful information. This manual is an important and integral part of your vehicle. [. . . ] License plate inspection. CAUTION Observe safety rules when conducting inspections. Exhaust gas contains harmful substance such as carbon monoxide. Do not carry out inspections on vehicle in closed places, or in poorly ventilated places, with engine running. Conduct inspections on flat, solid ground with the stand erected. Be careful of burns when conducting inspections immediately after engine is stopped because the engine and muffler are hot. Stop engine and remove the key prior to the vehicle maintenance service. If you are unable to correct trouble even after you make adjustment or correction, contact authorized maintenance shops, dealers or designated repair shops for necessary inspection and repairs. 21 INSPECTION OF CONCERNED AREA Check areas which caused for concern when last operating the vehicle. BRAKES The front brake is the hydraulic disk type, and the rear brake is the drum brake type. As the brake pad wear, the brake fluid level drops. There are no adjustments to perform, but fluid level and pad wear must be inspected periodically. The system must be inspected frequently to ensure there are no fluid leaks. [FRONT WHEEL] <BRAKE LEVER FREE PLAY> Lightly squeeze the brake levers until tension is felt to check for an appropriate amount of free play. No free play in the brake levers or overly loose brake levers are indication of a problem in the brake system. BRAKE LEVER FREE PLAY : 10~20mm <BRAKE FLUID LEVEL> WARNING Brake fluid may cause irritation. In case of contact, flush thoroughly with water and call a doctor if your eyes were exposed. Put main stand in upright position on a flat ground and operate steel wheel, and check fluid when the top of master cylinder cap is level. Check fluid level to see if it is below lower level. If fluid significantly low, it may indicate fluid leakage on brake system. If this happens, check fluid leaks or brake system. If this happens, check fluid leaks or damage on system and inspect joints and clamps for looseness. FUEL CHECK Check gasoline to see if there is a sufficient amount of gasoline to reach your destination. Refer to page 16 for refueling. 22 In addition, check hose and pipe protective part to sec if they make contact with other parts when you make left or right turn due to vibration during travel. LOWER LEVEL ENGINEC STOP <REPLENISHING BRAKE FLUID> Move steering wheel and set the top of reserve tank level. Clean dust and other foreign matter from around master cylinder and take caution not to allow foreign matter to fall inside master cylinder Open cap screw and remove diaphragm. Replenish recommended brake fluid to upper level inside master cylinder. [. . . ] Make sure that you can apply the brake anytime. Always apply the brake when stopping temporarily. Do not drive excessively long distance and take enough break. If any abnormality is found, stop driving and contact service center to inspect the vehicle. Restart the vehicle after 2~3 min when it is turned over. Always turn on the headlight at night. 49 STARTING Prior to starting always look around to avoid accident. [. . . ]