User manual DUCATI 996-2000

[. . . ] Owner's manual E DUCATI748/996 1 E 2 Hearty welcome among Ducati fans!Please accept our best compliments for choosing a Ducati motorcycle. We think you will ride your Ducati motorcycle for long journeys as well as short daily trips. Ducati Motor s. p. a wishes you smooth and enjoyable riding. [. . . ] Hydraulic oil is corrosive; it may cause damages and lead to severe injuries. Check for joint proper sealing. E MAX MIN fig. 29 41 Checking brake pads for wear (fig. 30) To facilitate inspection without removing the pads from the calipers, brake pads have a wear mark. If the grooves in the friction material are still visible, the pad is still in good condition. Important Have the brake pads replaced at a Ducati Dealer or Authorized Workshop. MIN yy ;; yy ;; yy ;; yy ;; yy ;; yy ;; yy ;; yy ;; yy ;; E fig. 30 42 Lubricating cables and joints The condition of the outer sheath of the throttle/starter cable should be checked at regular intervals. The sheath should show no signs of squeezing or cracking. Work the controls to make sure the cable slides smoothly inside the sheath: if you feel any friction or hard spots, have the cable replaced by a Ducati Dealer or Authorized Workshop. To prevent these failures, smear the end of the Bowden cable with SHELL Advance Grease or Retinax LX2 at regular intervals. For the throttle cable, it is best to open the device by unscrewing the two fastening screws (1, fig. 31. 1) and then grease the cable ends and the pulley. Warning When refitting the cover, be sure to slide the cable onto the suitable pulley. Refit the cover and tighten the screws (1). To ensure smooth operation of the side stand joint, clean off any dirt and apply SHELL Alvania R3 at all points exposed to friction. Throttle cable adjustment The throttle twistgrip must have a free play of 1. 5-2 mm measured at the edge of the twistgrip, at all positions of the handlebars. If it needs adjusting, use the suitable adjuster (2, fig. 31) provided on the throttle control. E 2 1, 5 ÷ 2 mm 1 fig. 32) Before charging the battery, it is best to remove it from the motorcycle. body panel (page 37), undo the screw (1) and remove the upper bracket. Always disconnect the black negative terminal (-) first, and then the red positive terminal (+). Warning Keep the battery out of the reach of children. A low battery will degrade soon if not charged promptly. Charge the battery at 1. 5 A. E Warning Batteries develop explosive gases: keep it away from heat sources and flames. [. . . ] Ducati will reimburse the owner for the expenses, including diagnosis, not to exceed Ducati's suggested retail price for all warranted 76 parts replaced and labor charges based on Ducati's recommended time allowance for the warranty repair and the geographically appropriate hourly labor rate. The owner may be required to keep receipts and failed parts in order to receive compensation. Limitations This Emission Control System Warranty shall not cover any of the following: A. Repair or replacement required as a result of (1) accident, (2) misuse, (3) repairs improperly performed or replacements improperly installed, (4) use of replacement parts or accessories not conforming to Ducati specifications which adversely affect performance and/or (5) use in competitive racing or related events. [. . . ]