User manual DUCATI MONSTER S4-2003

[. . . ] Owner's manual E DUCATIMONSTERS4 1 E 2 Hearty welcome among Ducati fans!Please accept out best compliments for choosing a Ducati motorcycle. We think you will ride your Ducati motorcycle for long journeys as well as short daily trips. Ducati Motor Holding S. p. A wishes you smooth and enjoyable riding. [. . . ] Warning When lowering the tank, make sure lines are properly routed to avoid squeezing. 1 E fig. 38) Replace the air filter at the required intervals shown in the routine maintenance chart (see Warranty Card) . The air box is accessible after lifting the fuel tank as described on page 39. To remove the filter, release the cover clips (1) on both sides of the air box and take off the cover (2). 39) and fit a new one. 2 E Important A clogged filter will reduce air intake, increase fuel consumption, reduce engine power, and foul the spark plugs. Do not use the motorcycle without filter or suspended matters could get into the engine and cause damage. Install the filter into the seat in the air box as shown in the figure and refit all the parts you have removed. Important If you are using the motorcycle on dusty or very wet roads, replace filter more frequently than recommended intervals shown in the routine maintenance chart (see Warranty Card). 1 fig. 39 40 Checking the coolant level (fig. 40) Check the coolant level in the expansion reservoir on the RH side of the motorcycle. The coolant level must be between the MAX and MIN marks. 40) and add a mixture consisting of water and antifreeze SHELL Advance Coolant or Glycoshell (35-40% of the volume) up to MAX mark. This mixture improves operating conditions (coolant will start freezing at ­20° C (-4 °F). Coolant circuit capacity: 3. 5 cu dm (liters). Warning Place the motorcycle on a flat surface and make sure the engine is cold before proceeding. 1 E MAX MIN fig. 40 41 Checking brake and clutch fluid level (fig. 41) Fluid level should never fall below the MIN mark on each reservoir. If level drops below the limit, air might get into the circuit and affect the operation of the system involved. Brake and clutch fluid must be topped up and changed at the intervals specified in the routine maintenance chart refer to the Warranty Card - by a Ducati dealer or authorized workshop. Clutch system If the control lever has exceeding play and the transmission snatches or jams as you try to engage a gear, it means that there is air in the circuit. Contact your Ducati dealer or an authorized workshop to have the system inspected and air drained out. Warning Clutch fluid level will increase as clutch plate friction material wears down. Do not exceed specified level (3 mm above minimum level). E Important It is recommended all brake and clutch tubes be changed every four years. Brake system If you find exceeding play on brake lever or pedal and brake pads are still in good condition, contact your Ducati dealer or an authorized workshop to have the system inspected and any air drained out of the circuit. [. . . ] Any replacement part can be used in an emergency repair. Ducati will reimburse the owner for the expenses, including diagnosis, not to exceed Ducati's suggested retail price for all warranted parts replaced and labor charges based on Ducati's recommended time allowance for the warranty repair and the geographically appropriate hourly labor rate. The owner may be required to keep receipts and failed parts in order to receive compensation. Limitations This Emission Control System Warranty shall not cover any of the following: A. [. . . ]