User manual ECHO SRM-225

[. . . ] Grass Trimmer/Brush Cutter Operator's Manual MODEL SRM-225 WARNING Read rules for safe operation and instructions carefully. ECHO provides an Operator's Manual and a Safety Manual. Both must be read and understood for proper and safe operation. Failure to do so could result in serious injury. X7722271603 X772000153 09/10 2 IntroductIon Welcome to the ECHO family. [. . . ] Regular scheduled maintenance will help your trimmer achieve that goal. If you are unsure or are not equipped with the necessary tools, you may want to take your unit to an ECHO Service Dealer for maintenance. To help you decide whether you want to DO-IT-YOURSELF or have the ECHO Dealer do it, each maintenance task has been graded. If the task is not listed, see your ECHO Dealer for repairs. WARNING skIll levels Level 1 = Level 2 = Easy to do. Some specialized tools may be required. ECHO offers REPOWERTM Maintenance Kits and Parts to make your maintenance job easier. maIntenance Intervals COMPONENT/ SYSTEM Air Filter Choke Shutter Fuel Filter Fuel Cap Gasket Fuel System Spark Plug Cooling System Muffler Spark Arrestor Cylinder Exhaust Port MAINTENANCE PROCEDURE Inspect/Clean Inspect/Clean Inspect/Replace Inspect/Replace Inspect/Replace Inspect/Clean Inspect/Clean Inspect/Clean/Replace Inspect/Clean/Decarbon REQ'D SKILL LEVEL 1 1 1 1 1 1 2 2 2 2 2 1 1 DAILY OR BEFORE USE I/C* I/C EVERY REFUEL 3 MONTHS OR 90 HOURS R* I* I* YEARLY 600 HOURS I/R* R* I (3) * I (3) * I/C/R* I/C I/C/R* I/C I (1) I (2) I/C* I* Drive Shaft (Flex Cable Grease Models) Gear Housing Recoil Starter Rope Screws/Nuts/Bolts Grease Inspect/Clean Inspect/Tighten/Replace MAINTENANCE PROCEDURE LETTER CODES: I = INSPECT, R = REPLACE, C = CLEAN IMPORTANT NOTE - Time intervals shown are maximum. Actual use and your experience will determine the frequency of required maintenance. MAINTENANCE PROCEDURE NOTES: (1) Apply POWER BLENDX TM grease every 25 hours of use. (2) Apply POWER BLENDX TM grease every 50 hours of use. (3) Low evaporative fuel tanks DO NOT require regular maintenance to maintain emission integrity. * Replacement is recommended based on the finding of damage or wear during inspection. Grass Trimmer/Brush CuTTer OperaTOr's manual aIr fIlter Level 1. REPOWERTM AIR & FUEL FILTER KIT. 19 Close choke (Cold Start Position [ ]). This prevents dirt from entering the carburetor throat when the air filter is removed. Brush accumulated dirt from air cleaner area. Remove air filter and lightly brush debris from filter. Replace filter if it is damaged, fuel soaked, very dirty, or the rubber sealing edges are deformed. If filter can be reused, be certain it: · Fits tightly in the air filter cavity. · Is installed with the original side out. Parts required: REPOWERTM AIR & FUEL FILTER KIT. Fuel is VERy flammable. Use extreme care when mixing, storing or handling, or serious personal injury may result. Use a clean rag to remove loose dirt from around fuel cap and empty fuel tank. Use the "fuel line hook" to pull the fuel line and filter from the tank. Remove the filter from the line and install the new filter. DANGER 20 spark plug Level 2. [. . . ] Any warranted part that is scheduled only for regular inspection in the written instructions supplied is warranted for the warranty period stated above. Any such part repaired or replaced under warranty will be warranted for the remaining ECHO Inc. Any emission related part scheduled for replacement during "required maintenance" is warranted for the period of time prior to the first scheduled replacement point for that part. Any such part repaired or replaced under warranty shall be warranted for the remainder of the period prior to the first scheduled replacement point for that part. [. . . ]