User manual ESPAR D1LC COMPACT

[. . . ] D1LC compact Air Heater Installation Troubleshooting & Parts Manual Espar D1LC compact For Heater Models 25 1976 05 - 12Volt 25 1977 05 - 24Volt 25 1965 05 - 12Volt 25 1966 05 - 24Volt 25 1895 05 - 12Volt 25 1896 05 - 24Volt Release period October/97-present Feburary/98-present April/97-October/97 August/96-Feburary/98 August/96-April/97 August/96-Limited April 1998 Table of Contents Page Introduction Heater Warnings Introduction Specifications Principal Dimensions Mounting Pattern Heater Components Heater Location Heater Mounting Heater Air Ducting Heater Plumbing Ducting Components Fuel System Electrical Connections Exhaust/Intake Connections Operating Switches Switch on Start-Up Temperature setting Temperature Control Switching Off Controls & Safety Equipment Operational Flow Chart Schematic 25 1976/1977 Schematic 25 1965/1966 Schematic 25 1895/1896 Periodic Maintenance Basic Troubleshooting Self Diagnostic Troubleshooting Fuel Quantity Test Component Spec chart Repair Steps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ] 6 5 Switch Off Once switched off either manually or automatically, the heater begins a controlled cool down cycle. · The fuel pump stops delivering fuel. · The glow plug is re-energized for a 15 second after-glow. · The blower continues to run for 3 minutes and automatically switches off. Controls and Safety Equipment · If the heater fails to ignite within two 90 second start attempts, a "no start" shut down occurs. · If a flame out occurs after the heater has started, the heater will attempt to restart. · If repeated flame outs occur within 10 minutes the heater will not restart. · Overheat shut down will occur if there is a restriction of the heating air flow (i. e. The overheat switch will automatically reset once the heater has cooled down. Once the air flow restriction is removed, the heater can be re-started by switching the heater off then back on. · If the voltage drops below 10. 5 volts or rises above 15. 9 volts the heater will shut down (21volts and 30 volts for 24 volt systems). · If the glow plug circuit or fuel metering pump circuit are interrupted the heater will not start. 3 Temperature Setting Using the adjusting dial, set the desired temperature range. From 1-4 · Lowest Setting - approx. 10°C (50°F) · Mid - Setting - approx. 18°C (65°F) · Highest Setting - approx. 30°C (85°F) Operation indicating light Low High · The blower motor is checked on start up and every 4 minutes. Shut down will occur if the blower does not start or maintain proper speed. 14 Operational Flow Chart 15 Wiring Diagram D1LCcompact Models: 25 1976 05 (12v) 25 1977 05 (24v) 16 Wiring Diagram D1LCcompact Models: 25 1965 05 (12v) 25 1966 05 (24v) 17 Wiring Diagram D1LCcompact Models: 25 1895 05 (12v) 25 1896 05 (24v) 18 Maintenance, Troubleshooting and Repairs Recommended Periodic Maintenance · Remove the glow plug and inspect for carbon build up. · Remove the glow plug screen and inspect for carbon build up. If cleaning is required, use brass brush (Espar part number CA0 05 003). Espar recommends the use of non detergent 100% volatile carburetor cleaner and an air gun will also help. Remove loose carbon from the glow plug chamber. · Inspect the ducting, the air intake screen and air outlet for restriction or blockage. [. . . ] (2) · Unplug overheat switch and flame sensor connectors. 3 · Re-install in reverse order. Control Unit 24 Heater Casing Disassembly · Remove internal hex screw and cap. · Pry off air outlet hood using a flat screw driver. · Remove rivets by punching center pin through and prying out base. [. . . ]