User manual FORD F250-2001

[. . . ] Reproduction by any means, electronic or mechanical including photocopying, recording or by any information storage and retrieval system or translation in whole or part is not permitted without written authorization from Ford Motor Company. Ford may change the contents without notice and without incurring obligation. Copyright © 2000 Ford Motor Company 2 Find Your Way Find Your Way Symbol Key Cars and Minivans Light Trucks, Sport Utilities, and Vans 4x4 Vehicles Diesel Natural Gas Vehicles (NGV) and Propane Towing a trailer or using a camper or car-top carrier Extensive idling and/or low-speed driving for long distances as in heavy commercial use such as delivery, taxi, patrol car or livery Operating in dusty conditions such as unpaved or dusty roads Off-road operation 3 General Maintenance Information General Maintenance Information Why Maintain Your Vehicle? This guide describes the scheduled maintenance required for your vehicle. Carefully following this schedule helps protect against major repair expenses resulting from neglect or inadequate maintenance and may also help to increase the value of your vehicle when you sell or trade it. [. . . ] Additional services for: Diesel Check air filter minder, replace filter as required 10 Normal Schedule Normal Schedule 15, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect automatic transmission fluid level, if equipped with dipstick Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system Inspect engine cooling system and hoses Inspect steering linkage, suspension, and if equipped driveshaft and ball joints Inspect tires for wear and rotate Replace cabin air filter, if equipped Additional services for: Light Trucks, Sport Utilities, and Vans Inspect and lubricate 4X2 ball joints (except F-450/F-550) Inspect and lubricate steering linkage (E and F Series, Expedition, Navigator, Excursion) Additional services for: Diesel Check air filter minder, replace filter as required Replace fuel filter Add coolant supplement additive as per the owner guide supplement (except invehicles with yellow coolant) 11 Normal Schedule Normal Schedule 20, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect tires for wear. Rotation recommended for optimal tire life. Additional services for: Diesel Check air filter minder, replace filter as required 25, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect tires for wear. Rotation recommended for optimal tire life. Additional services for: Diesel Check air filter minder, replace filter as required 12 Normal Schedule Normal Schedule 30, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system Inspect engine cooling system and hoses Inspect exhaust system and heat shields Inspect steering linkage, suspension, and if equipped driveshaft and ball joints Inspect tires for wear and rotate Replace engine air filter Replace fuel filter* Replace cabin air filter, if equipped Inspect accessory drive belt(s) (Villager and Escort) Change automatic transmission/transaxle fluid on all vehicles equipped with AX4S, 4F50N, 4R70W, 4R100, 4F27E. Inspect automatic transmission fluid level on all other vehicles, if equipped with dipstick. Consult your dealer for your particular requirements. Rotation recommended for optimal tire life. Additional services for: Diesel Check air filter minder, replace filter as required 16 Normal Schedule Normal Schedule 55, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect tires for wear. Rotation recommended for optimal tire life. Additional services for: Diesel Check air filter minder, replace filter as required 60, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system Inspect engine cooling system and hoses Inspect exhaust system and heat shields Inspect steering linkage, suspension, and if equipped driveshaft and ball joints Inspect tires for wear and rotate Replace engine air filter 17 Normal Schedule Normal Schedule Replace fuel filter* Replace cabin air filter, if equipped Replace accessory drive belt(s) (Villager and Escort) Change automatic transmission/transaxle fluid on all vehicles equipped with AX4S, 4F50N, 4R70W, 4R100, 4F27E. Inspect automatic transmission fluid level on all other vehicles, if equipped with dipstick. Consult your dealer for your particular requirements. Replace climate-controlled seat filters (Navigator, if equipped) Change manual transmission fluid (Lincoln LS only) Additional services for: Light Trucks, Sport Utilities, and Vans Inspect and lubricate 4X2 ball joints (except F-450/F-550) Lubricate 4X2 wheel bearings, replace grease seals, and adjust bearings Change manual transmission fluid Inspect and lubricate steering linkage (E and F Series, Expedition, Navigator, Excursion) Additional services for: Diesel Check air filter minder, replace filter as required Replace fuel filter Add coolant supplement additive as per the owner guide supplement (except in vehicles with yellow coolant) * If vehicle is registered in California, the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle's useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded. 18 Normal Schedule Normal Schedule Additional services for: Natural Gas and Propane Vehicles Inspect fuel tanks Drain coalescent fuel filter bowl and replace filter 65, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect tires for wear. Rotation recommended for optimal tire life. Additional services for: Diesel Check air filter minder, replace filter as required 70, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect tires for wear. Rotation recommended for optimal tire life. 19 Normal Schedule Normal Schedule Additional services for: Diesel Check air filter minder, replace filter as required 75, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect automatic transmission fluid level, if equipped with dipstick Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system Inspect engine cooling system and hoses Inspect steering linkage, suspension, and if equipped driveshaft and ball joints Inspect tires for wear and rotate Replace cabin air filter, if equipped Change yellow or green engine coolant, if equipped Additional services for: Light Trucks, Sport Utilities, and Vans Inspect and lubricate 4X2 ball joints (except F-450/F-550) Inspect and lubricate steering linkage (E and F Series, Expedition, Navigator, Excursion) 20 Normal Schedule Normal Schedule Additional services for: Diesel Check air filter minder, replace filter as required Replace fuel filter 80, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect tires for wear. Rotation recommended for optimal tire life. Additional services for: Diesel Check air filter minder, replace filter as required 85, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect tires for wear. Rotation recommended for optimal tire life. 21 Normal Schedule Normal Schedule Additional services for: Diesel Check air filter minder, replace filter as required 90, 000 miles Cars, Minivans, Light Trucks, Sport Utilities, Vans, 4x4, Natural Gas, Propane, and Diesel Vehicles Change engine oil and replace oil filter Inspect brake pads/shoes/rotors/drums, brake lines & hoses, and parking brake system Inspect engine cooling system and hoses Inspect exhaust system and heat shields Inspect steering linkage, suspension, and if equipped driveshaft and ball joints Inspect tires for wear and rotate Replace engine air filter Replace fuel filter* Replace cabin air filter, if equipped Inspect accessory drive belt(s) (Villager and Escort) Change automatic transmission/transaxle fluid on all vehicles equipped with AX4S, 4F50N, 4R70W, 4R100, 4F27E. Inspect automatic transmission fluid level on all other vehicles, if equipped with dipstick. [. . . ] Rear axle lubricant change may be waived if the axle was filled with 75W140 synthetic gear lubricant meeting Ford specification WSL-M2C192-A, part number FITZ-19580-B or equivalent. Add four ounces of additive friction modifier C8AZ-19B546-A (EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear axles. The rear axle lubricant should be changed anytime the axle has been submerged in water. F-450 and F-550 Axle Maintenance Replace rear axle lubricant every 100, 000 miles under normal driving conditions on all F-450 and F-550 commercial applications. [. . . ]