User manual GAI-TRONICS 10457-040 FULL BACKPLANE

[. . . ] 42004-721L2B Page 2 of 5 Hardware Configuration Figure 1. 10457-040 Full Backplane Card Rack Assembly f:\standard ioms - current release\42004 instr. manuals\42004-721l2b. doc 11/10 10457-040 FULL BACKPLANE CARD RACK ASSEMBLY Pub. 42004-721L2B Page 3 of 5 Installation Direct questions about installation of this product to GAI-Tronics' Field Service Department at 800-4921212 inside the USA or 610-777-1374 outside the USA. Installation Guidelines Please adhere to all warnings, safety, and operating instructions on the unit and in the installation manual. [. . . ] AC power is supplied to the card rack via the ac line cord connector. NOTE: The power cord (GAI-Tronics Part No. It is packaged as part of the 10457-040 Card Rack Assembly. f:\standard ioms - current release\42004 instr. manuals\42004-721l2b. doc 11/10 10457-040 FULL BACKPLANE CARD RACK ASSEMBLY Pub. 42004-721L2B Page 4 of 5 Maintenance Troubleshooting Problem Action Power lights on the MCU PCBA do not illuminate. 1. Verify the MCU is fully seated in the card rack. Call for service of the applicable power supply. Plug-in cards do not operate in one of the slots. 1. Check slot with a known good plug-in card. Call for service of the backplane PCBAs. Specifications Electrical Power supply. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Each supply is fused at 2 A, 250 V (not user-serviceable) Input voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120 V ac/240 V ac Total power consumed (card dependent). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 336 VA, 212 W maximum Input frequency range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50/60 Hz Input surge current (cold start) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Less than 40 A peak max. not to exceed each power supply's total output power): (current based on convection cooling) 5 V power supply. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . output 1 = 16 A @ +5 V dc +/-12 V power supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . output 1 = 5 A @ 12 V dc output 2 = 4A @ -12 V dc Total output power of each supply (50º C ambient temp. continuous) Convection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Conducted EMI. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Compliance to EN55022 AC input power connector (rear). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . IEC 320-style, 3-pin f:\standard ioms - current release\42004 instr. manuals\42004-721l2b. doc 11/10 10457-040 FULL BACKPLANE CARD RACK ASSEMBLY Environmental Pub. 42004-721L2B Page 5 of 5 Temperature operating. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ] The applicability of any such third-party warranty will be determined by GAI-Tronics. Services. Any services GAI-Tronics provides hereunder, whether directly or through subcontractors, shall be performed in accordance with the standard of care with which such services are normally provided in the industry. If the services fail to meet the applicable industry standard, GAI-Tronics will re-perform such services at no cost to buyer to correct said deficiency to Company's satisfaction provided any and all issues are identified prior to the demobilization of the Contractor's personnel from the work site. Re-performance of services shall be Buyer's sole and exclusive remedy, and in no event shall GAITronics warranty obligations with respect to services exceed 100% of the total cost of the services provided hereunder. Warranty Periods. Every claim by Buyer alleging a defect in the goods and/or services provided hereunder shall be deemed waived unless such claim is made in writing within the applicable warranty periods as set forth above. Provided, however, that if the defect complained of is latent and not discoverable within the above warranty periods, every claim arising on account of such latent defect shall be deemed waived unless it is made in writing within a reasonable time after such latent defect is or should have been discovered by Buyer. Limitations / Exclusions. The warranties herein shall not apply to, and GAI-Tronics shall not be responsible for, any damage to the goods or failure of the services supplied hereunder, to the extent caused by Buyer's neglect, failure to follow operational and maintenance procedures provided with the equipment, or the use of technicians not specifically authorized by GAI-Tronics to maintain or service the equipment. [. . . ]