User manual GAS GAS K2 QUAD 50

[. . . ] 4 STROKE 50 MANUAL DEL USUARIO USER MANUAL MANUEL D'ENTRETIEN LIBRETTO D´USO BETRIEBSANLEITUNG 50 4 STROKE SERVICE MANUAL ENGLISH INTRODUCTION Congratulations on your purchase of QUAD 50 - 4 STROKE it represents the result of many years of our experience in the production of fine machines. You can now appreciate our craftsmanship and reliability of the master piece. This manual will provide you with a good basic understanding of the features and operation of this machine. This manual includes important safety information. [. . . ] The cap of the switch tied to a rope is normally connected to the safety switch when riding the vehicle. This rope should never be attached to the rider. The supervisor should hold the safety switch behind the vehicle and pull the rope to activate the safety switch if necessary. The engine will stop automatically when the switch cap is off from the switch. OFF Switch mark " " If the lever is in this position. fuel will not flow, Alaways turn the lever to this position when the engine is not runing. · ON Switch mark " " If the lever is in this position, fuel flows to the carburetor. Normal riding is done with the lever on this position. FUEL a. Fuel valve The three way fuel valve is on the left side of the vehicle. -13- Res Switch mark " " After refueling return the fuel cock lever to the "ON" position. when your QUAD run out of fuel while riding, Turn the fuel cock from "ON" to "Res", you can run your QUAD for a few minutes. b. Fuel tank Fuel tank capacity is 3. 2liter (0. 87gal). gasoline with octane number of 91 or higher may be used. After refueling, be sure to tighten the tank cap firmly. Do not refuel-right after the engine has been running and still very hot. ENGINE OIL Four-stroke engine oil must be added to the Cramkoorp periodically. check oil indicator every time before operating this vehicle. If oil supply to engine is not enough, the machine will be out of order. it can not work again. you can refill the oil into the cramkcase behind the engine. -14- The pressure should be checked when the tires are "cold" before running the vehicle. Tire wear limit When the tire groove decreases to 3mm (0. 1" ) due to wear. Oil hole Light switch The light swith is on the left handbar. when the switch is on the mark " ", it means to turn off light. Be sure to push the switch to the mark "HL" position. the light is turned on. · TIRES Check tire pressure frequently with the air pressure gauge. Tire should be inflated to the recommended pressure. Recommended: FRONT: 20kpa, (0. 2 kgf/ cm2), 2. 8 psi REAR: 20kPA, (0. 2 KGF/CM2), 2. 8 psi Minimum: FRONT:17Kpa, (0. 17 kgf/cm2), 2. 4 psi REAR: 17Kpa, (0. 17 kgf/cm2), 2. 4 psi OPERATION INSPECTION Inspect your vehicle every day before you run it. [. . . ] During the first six months subsequent to the delivery of the repaired vehicle, the seller will be responsible for any unwarranted faults arising out of the repair. Any defects detected in the product must be brought to the attention of a GG authorised dealer within the Warranty Period. If the last day of this period is a Sunday or an official holiday, the Warranty period will be extended such that the last day of the period covered will be the first working day after the Sunday or official holiday. Those claims under Warranty for defects not brought to the attention of a GG authorised dealer before the end of the Warranty Period will be excluded. -26- Obligation of the purchaser GG will have the right to reject any claims under Warranty in the event that: a) The purchaser has failed to submit the vehicle to any of the inspections and/or maintenance work required in the Users' Manual, or has exceeded the date set for such inspections or maintenance work. [. . . ]