User manual HATCO 3CSFR

[. . . ] Cualquier falla en el seguimiento de las instrucciones contenidas en este manual puede resultar en un serio daño. Si usted no puede entender el contenido de este manual por favor pregunte a su supervisor. No opere este equipo al menos que haya leído y comprendido el contenido de este manual. CONTENTS Important Owner Information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . i Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . i Important Safety Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Model Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 All GRCD Models. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 All 3CSFR Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Electrical Rating Chart-GRCD Models . . . . . . . . . . . . . . . 5 Electrical Rating Chart-3CSFR Models . . . . . . . . . . . . . . . 7 Plug Configurations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 Dimensions-GRCD Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 Dimensions-3CSFR Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 All Models. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 GRCD Models. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 3CSFR Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 Location. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 Non-Humidified Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 Humidified Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 Removing Lime & Mineral Deposits. . . . . . . . . . . . . . . . . 16 Display Light Bulb Replacement. . . . . . . . . . . . . . . . . . . . . . . 17 Accessories. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 Hatco Limited Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Authorized Parts Distributors. . . . . . . . . . . . . . . . . Back Cover IMPORTANT OWNER INFORMATION Record the model number, serial number (located on the back of the unit), voltage and purchase date of your Glo-Ray® Heated Display Case in the spaces below. Please have this information available when calling Hatco for service assistance. [. . . ] Install legs to bottom of unit as shown in Figure 8. NOTE: If your unit is equipped with optional Slant Leg Kit, see Accessories for installation instructions. CAUTION Do not lay unit on the side with the control panel or the front of a curved glass unit, damage to unit could occur. NOTE: Legs are adjustable for leveling the unit. Use a 9/16" (14 mm) open-end wrench to make leveling adjustments once the unit is placed in final position. Remove tape and protective film from all surfaces of unit. Install pan rail (3CSFR units) or pan skirt, divider and water trough (3CSFRH units). NOTE: If your unit is equipped with optional Sandwich Chutes and/or Display Sign Holder, see Accessories for installation instructions. Pan Divider (3CSFRH models) Side Glass Water Trough (3CSFRH models) Rear Doors Door Glides (2 ea. door) Pan Rail (3CSFR models) Pan Skirt (3CSFRH models) Figure 10. Exploded View - 3CSFR Models Form No. GRCD/HDM-0703 12 INSTALLATION LOCATION - ALL MODELS !Control Panel ­ Non-Humidified Models NON-HUMIDIFIED MODELS 1. Plug cabinet into a properly grounded electrical outlet of the correct voltage, size and plug configuration. Turn the Power Switch to the ON position. On start-up set all heat controls at maximum to assure safe food holding. On dual tier models, the Top and Center Heat Indicators will light when controls are in the ON position. NOTE: Temperature settings may vary depending upon product make-up and consistency. Allow unit 30 minutes to reach operating temperature. Form No. GRCD/HDM-0703 14 OPERATION HUMIDIFIED MODELS 1. Plug cabinet into a properly grounded electrical outlet of the correct voltage, size and plug configuration. Remove the center slotted pan divider from the water trough. Turn the Power Switch to the ON position. [. . . ] San Antonio 210-532-1660 UTAH GCS Service Salt Lake City VIRGINIA Daubers Norfolk Daubers Springfield WASHINGTON Restaurant Appl. Service Seattle 206-524-8200 WISCONSIN A. S. C. , Inc. Milwaukee 608-246-3160 414-543-6460 757-855-4097 703-866-3600 801-487-3653 Chapman Appl. Service San Diego 619-298-7106 P & D Appliance S. [. . . ]