User manual HERRMIDIFIER G-100ES

[. . . ] G-100ES Duct Mount Humidifier Installation · Operation · Maintenance CAUTION: READ INSTALLATION, OPERATION, AND MAINTENANCE INSTRUCTIONS CAREFULLY FOR SAFE OPERATION. EXERCISE EXTREME CAUTION WHEN WORKING WITH ELECTRICITY. 252907-001 9/04 Table of Contents Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Capacity Selection Guide. . . . . . . . . . . . . . . . . . . . . . 3 Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Mounting Locations . . . . . . . . . . . . . . . . . . . . . . . . 6 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 Description of Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 Unit Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 Introduction Introduction The benefits of a properly humidified environment (35-50%, Relative Humidity) are many. They include both personal comfort as well as the preservation of furniture, draperies, carpets, wooden floors and cabinets, paintings, pianos, etc. . Your home will be more comfortable at a lower temperature (i. e. : 68° F) at 30-40% Relative Humidity (RH) than at 71° to 72° F without controlled humidity. [. . . ] Bacteria or fungi may appear on the water surface, the sides, or bottom of your humidifier. A crusty deposit or scale may also appear and is composed of minerals that have settled out of the water. Annual cleaning is required for the efficient and safe operation of this humidifier. However, more frequent maintenance and cleaning may be required in areas of poor water quality. During the first heating season, check for scale buildup on a monthly basis and establish the proper cleaning schedule. Failure to do so can result in reduced efficiency and/or water damage to house and property. If frequent cleaning of the humidifier is required, a sediment filter should be installed upstream of the conical mesh filter to reduce the frequency of cleaning. Water softeners can be used to improve the quality of the supply water, however, deionized water is corrosive and can reduce the operating life of your unit. To Inspect and Clean the Conical Mesh Water Filter 1. Turn OFF the water supply at the saddle valve by turning the valve handle clockwise. Disconnect the water line from the INLET fitting of the solenoid valve using two (2) wrenches, one for the compression nut and one on the INLET fitting. Remove the conical mesh filter from inside the inlet fitting using a small nail or paper clip. NOTE: Be careful not to puncture the filter. Replace the filter and reconnect the water line to the INLET fitting reversing the directions in Step 2. Turn the water back ON at the saddle valve. To Inspect and Clean the Fluid Restrictor 1. Turn OFF the water supply at the saddle valve by turning the valve handle clockwise. Disconnect the water line from the OUTLET fitting of the solenoid valve using two (2) wrenches, one for the compression nut and one on the OUTLET fitting. Locate the fluid restrictor, inside the end of the water line, and inspect it for sediment clogging and accumulation. Clean or replace fluid restrictor as needed. NOTE: Do NOT attempt to enlarge the hole size in the restrictor. Reconnect the water line to the OUTLET fitting reversing the directions in Step 2. [. . . ] Holes in tray must be cleaned periodically. 11 Parts list Item Description G-100ES Assembly 1 2 3 4 5 6 7 7a 8 9 10 11 12 12a 13 14 15 16 17 17a Base Brass solenoid valve assembly 24VAC Replacement cone mesh filters (12 pack only) Drain tray assembly Replacement evaporator pads (6 pack only) Fan blade 9" Fan motor 120VAC Fan motor 220-240VAC Replacement fluid restrictors (12 pack only) Motor cover Relay 24VAC Shroud Transformer 120VAC/24VAC Transformer 220-240VAC/24VAC Unit cover Water distribution tray Saddle valve assembly Humidistat Capacitor 120VAC Capacitor 220-240VAC Part Number 351453-001 454275-002 251461-001 G-125-12 353226-001 G-116-6 G-110 252716-001 G-128-12 454276-002 G-177 454277-002 G-139 454274-002 G-105 IN-2ST 352680-004 257241-001 - Part Number 351453-011 454275-002 251461-001 G-125-12 353226-001 G-116-6 G-110 252716-002 G-128-12 454276-002 G-177 454277-002 256592-001 454274-002 G-105 IN-2ST 352680-004 257241-002 12 Unit Diagram 14 15 5 1 16 4 11 9 13 6 12 7 10 17 3 8 2 13 Warranty Humidifier Limited Two Year Warranty This limited warranty covers Herrmidifier Residential Type Humidifiers, excluding duct work, wiring and installation. The manufacturer warrants that all new Herrmidifier Humidifiers are free from defects in material and workmanship under normal, non-commercial use and service. The manufacturer will remedy any covered defects if they appear within 24 months from the date of original installation as evidenced by proof of purchase, subject to the terms and conditions of this Limited Two-Year Warranty stated below: 1. THIS LIMITED TWO-YEAR WARRANTY is granted by CareCo, 415 W. [. . . ]