User manual HP PAVILION ZE5640EA MAINTENANCE AND SERVICE GUIDE

[. . . ] HP Pavilion ze5600 Notebook PC HP Pavilion ze5500 Notebook PC HP Pavilion ze5400 Notebook PC HP Pavilion ze5300 Notebook PC HP Pavilion ze5200 Notebook PC HP Pavilion ze4700 Notebook PC HP Pavilion ze4600 Notebook PC HP Pavilion ze4500 Notebook PC HP Pavilion ze4400 Notebook PC HP Pavilion ze4300 Notebook PC HP Pavilion ze4200 Notebook PC HP Pavilion ze4100 Notebook PC HP Compaq nx9010 Notebook PC HP Compaq nx9008 Notebook PC HP Compaq nx9005 Notebook PC HP Compaq nx9000 Notebook PC Compaq Evo Notebook N1050v Series Compaq Evo Notebook N1010v Series Compaq Presario 2500 Series Mobile PC Compaq Presario 2100 Series Mobile PC Compaq Presario 1100 Series Mobile PC (All Models use technology code KE) Service Manual © Copyright 2003, 2004 Hewlett-Packard Development Company, L. P. registered trademarks of Microsoft Corporation. Intel, Celeron, and Pentium are trademarks or registered trademarks of Intel Corporation or its subsidiaries in the United States and other countries. The information contained herein is subject to change without notice. [. . . ] Remove these additional assemblies: · · · · · · Hard disk drive (page 2-9) Keyboard cover (page 2-13) Keyboard (page 2-16) Switchboard PCA (page 2-19) Display assembly (page 2-23) Top case (page 2-26) Service Manual Removal and Replacement 2-39 3. Disconnect the 2 fan cables from the motherboard. Remove the 4 retaining M2. 0×5. 0mm screws in the "1, " "2, " "3, " "4" sequence stamped on the heat sink. Lift up on the heat sink (with fan). Figure 2-27. Removing the Heat Sink (with Fan) HP Pavilion 5x00, HP Compaq nx9010 and nx9008, and Compaq Presario 2500 Models CAUTION: Do not spin the fan blades with your finger or you could damage the fan's bearings. Reassembly Notes · · If the thermal pad is damaged, use a sharp knife or scraper to carefully remove it from the heat sink, and then attach a new thermal pad. Install the heat sink screws in this order: 1. Fully tighten the screws in the order stamped on the heat sink. 2-40 Removal and Replacement Service Manual Removing the CPU Module (Authorized Service Providers Only) Required Equipment Small flat-blade (3mm) screwdriver NOTE: This section applies only to HP Pavilion 4x00, HP Compaq nx9005 and nx9000, Compaq Evo Notebook N1050v and N1010v, and Compaq Presario 2100 and 1100 models. Removal Procedure 1. Unplug the AC adapter, if present, and then remove the battery. Remove these additional assemblies: · · · · · · · Hard disk drive (page 2-9) Keyboard cover (page 2-13) Keyboard (page 2-16) Switchboard PCA (page 2-19) Display assembly (page 2-23) Top case (page 2-26) Heat sink (page 2-40) Service Manual Removal and Replacement 2-41 3. Depending on model configuration, an Intel or an AMD CPU module mey be installed. For models using an AMD CPU, proceed to step 4. On models using an Intel CPU, proceed with the following substeps: a. Turn the lock screw one-half turn counterclockwise (you should here a light snap) to release the CPU module ( see Figure 2-28). Carefully lift the CPU module off the socket on the motherboard. Figure 2-28. Intel CPU Module Removal HP Pavilion 4x00, HP Compaq nx9005 and nx9000, Compaq Evo Notebook N1050v and N1010v, and Compaq Presario 2100 and 1100 Models CAUTION: Each time you install a new CPU module, you must also replace the heat sink's thermal pad to maintain optimum heat transfer. Use a sharp knife or scraper to carefully remove the old thermal pad from the heat sink, and then attach the new thermal pad. To install, carefullu insert the CPU module into the motherboard (the CPU module is keyed for installation and can be inserted only one way). Turn the lock screw one-half turn clockwise to secure the CPU module. 2-42 Removal and Replacement Service Manual 4. On models using an AMD CPU, proceed with the following substeps: a. Place a flat-blade screwdriver (with a 3mm blade) into the slot at the angle shown in Figure 2-29 and move the screwdriver in the directon shown by the arrow until a Select is felt or heard. Figure 2-29 AMD CPU Module Release HP Pavilion 4x00, HP Compaq nx9005 and nx9000, Compaq Evo Notebook N1050v and N1010v, and Compaq Presario 2100 and 1100 Models b. Carefully grasp the CPU module bythe edges and lift the module off the socket on the motherboard (see Figure 2-30). Figure 2-30. AMD CPU Module Removal HP Pavilion 4x00, HP Compaq nx9005 and nx9000, Compaq Evo Notebook N1050v and N1010v, and Compaq Presario 2100 and 1100 Models Service Manual Removal and Replacement 2-43 c. [. . . ] After you select the options you want, press F10 or use the Exit menu to exit BIOS Setup. If the settings cause a conflict between devices during reboot, the system prompts you to run BIOS Setup, and marks the conflicting settings. NOTE: The listings in the following table are for the initial BIOS release and might differ somewhat for other models Service Manual Troubleshooting and Diagnostics 3-33 Table 3-7 BIOS Setup Menus and Parameters All notebook models: Introduced with BIOS version KE. 01. 04 (Fall 2002) Main Menu BIOS Revision System Time System Date Language Internal Hard Disk Extended Memory CPU Serial Number Serial Number PC ID Service ID UUID MAC Address Description Shows the current BIOS version Sets the time using 24-hour format Values set take effect immediately Sets the date using dd/mm/yy format (except English, which uses mm/dd/yy format) Sets the language for BIOS Setup Sets the hard disk drive type and various parameters Shows the extended memory size For a Pentium processor with a serial number, makes the serial number available to software Displays the serial number as shown on the back of the notebook Displays the PC ID String stored in the reserved part of RAM Displays an identifier used for repair service Displays the value of the 16-byte UUID (Universally Unique ID) as 32 hex characters Displays the MAC network address of the internal (wired) LAN, if present Default Detected automatically Detected automatically Detected automatically Detected automatically Disabled Detected automatically Detected automatically Detected automatically Detected automatically 3-34 Troubleshooting and Diagnostics Service Manual System Devices Menu Video Display Device External Pointing Devices Legacy USB Support Description Sets whether the built-in display automatically switches to an external display, if one is detected Disables the internal pointing devices when an external pointing device is connected Enables BIOS support for USB mouse, keyboard, and floppy drive during startup Lets the notebook be turned on via the LAN port If this option is enabled, the notebook uses increased power while it is shut down Default Auto Auto Enabled Wake On LAN from Power Off Disabled Security Menu User Password is Administrator Password is Set User Password Description Shows if a user password is set Shows if an administrator password is set Press enter to set, change, or clear the user password The password can have no more than 8 characters (0-9, A-Z), and cannot include special or accented characters Press enter to set, change, or clear the administrator password, which protects BIOS Setup settings The password can have no more than 8 characters (0-9, A-Z), and cannot include special or accented characters Sets whether a user password is required when the computer boots Requires the administrator password for changes Default Clear Clear Enter Set Administrator Password Enter Password Required to Boot Disabled Boot Menu Hard Disk Removable Device CD/DVD Built-in LAN Description Shows the order of boot devices Move the entries to change the order Built-in LAN provides diskless boot from a network server Default 1. Built-in LAN Exit Menu Save Changes and Exit Discard Changes and Exit Get Default Values Description Saves Setup changes, and then exits and reboots Discards any Setup changes made since last save, and then exits and reboots Does not affect password, date, or time changes Restores default settings, and remains in Setup Does not affect password, date, or time changes Updating the Notebook's BIOS Hewlett-Packard might from time to time provide updates to the notebook's BIOS Use e-DiagTools for Windows to download and install these BIOS updates as needed (page 2-61). Service Manual Troubleshooting and Diagnostics 3-35 4 Replaceable Parts This chapter contains an exploded view of the notebook and the following lists of parts: · · · Notebook replaceable parts (page 4-3) Accessory replacement parts (page 4-11) Part number reference (page 4-12) Service Manual Replaceable Parts 4-1 Figure 4-1 Exploded View HP Pavilion 4x00, HP Compaq nx9005 and nx9000, and Compaq Presario 2100 4-2 Replaceable Parts Service Manual Figure 4-2 Exploded View HP Pavilion 5x00, HP Compaq nx9010 and nx9008, and Compaq Presario 2500 Service Manual Replaceable Parts 4-3 Table 4-1 Replaceable Parts Pavilion ze4x00, Evo N1050v, and Presario 2100 Pavilion ze4200, nx9000, and Presario 2100 Evo N1010, and Presario 1100 F5771J Pavilion ze4100 F5761H User Repl No Description 1 Cover, Keyboard­ 1F Pavilion Cover, Keyboard­ 1F Compaq SPS-COVER, KEYBOARD W/SPEAKERS CPQ SPS-COVER, KEYBOARD W/SPEAKERS PAV Display 150-inch SXGA+­ Pavilion KE Display 150-inch XGA­Pavilion KE Display 141-inch XGA­Pavilion KE Display 150-inch SXGA+­ (Compaq) Display 150-inch XGA­(Compaq) Display 141-inch XGA­(Compaq) SPS-DSPLY PANEL 141-inch XGA PAV SPS-DSPLY PANEL 150-inch XGA PAV SPS-DSPLY PANEL 150-inch SXGA PAV SPS-DSPLY PANEL 141-inch SGA PRES SPS-DSPLY PANEL 150-inch SGA PRES Part Number F576160904 319428-001 F577160904 319430-001 319479-001 Exchange Part Number Pavilion ze5x00, nx9010, nx9008, and Presario 2500 · · · · · 1 No 1 · No 1 323099-001 · No 2 F576160912 F576160911 319437-001 F576160910 319436-001 F577160903 F577160902 F577160901 319483-001 F576169012 F576169011 F576169010 F577169003 F577169002 F577169001 · · · · · · · · · · · · No 2 No 2 No 2 No 2 2 2 No No No · 2 319484-001 · No 2 319485-001 · No 2 319486-001 · No 2 319487-001 · No 4-4 Replaceable Parts Service Manual Description 2 SPS-DSPLY PANEL 150-inch SXGA PRES SPS-DSPLY PANEL 150-inch SXGA CPQ SPS-DSPLY PANEL 150-inch XGA CPQ SPS-DSPLY PANEL 141-inch XGA CPQ Speaker assy­1F Part Number 319488-001 Exchange Part Number Pavilion ze5x00, nx9010, nx9008, and Presario 2500 Pavilion ze4x00, Evo N1050v, and Presario 2100 Pavilion ze4200, nx9000, and Presario 2100 Evo N1010, and Presario 1100 F5771J Pavilion ze4100 F5761H User Repl No · 2 319441-001 · · No 2 319440-001 · · No 2 319439-001 · · No 3 F464060908 319447-001 F576160905 317445-001 F464060933 F464060909 317443-171 F464060910 317443-181 317443-201 F464060911 317443-221 F464060912 317443-081 317443-021 F464060913 317443-051 F464060914 317443-121 F464060915 317443-041 · · · · · · · No 4 PCA, switchboard w/cable 1F Pavilion PCA, switchboard w/cable 1F SPSKEYBOARD-AR SPSKEYBOARD-BEL SPSKEYBOARD-BR SPSKEYBOARD-CZ SPSKEYBOARD-DEN SPSKEYBOARD-EUR Keybd, FRENCH No 4 5 No No · · · · · · · · · · · · · · · · 5 No 5 5 No No 5 No 5 5 No · · · · · No 5 SPSKEYBOARD-FC Keybd, GERMAN No 5 No Service Manual Replaceable Parts 4-5 Description 5 SPSKEYBOARD-GRK SPSKEYBOARD-HE SPSKEYBOARD-HUN SPSKEYBOARD-ICL SPSKEYBOARD-INTL Keybd, ITALIAN Part Number F464060916 317443-151 F464060917 317443-BB1 F464060918 317443-211 317443-DD1 F464060920 317443-002 F464060921 317443-061 F464060922 317443-291 317443-AD1 317443-161 F464060923 317443-091 F464060929 317443-AA1 F464060924 317443-131 F464060925 317443-251 317443-231 F464060926 317443-071 F464060927 317443-101 F464060928 317443-111 317443-AB1 Exchange Part Number Pavilion ze5x00, nx9010, nx9008, and Presario 2500 Pavilion ze4x00, Evo N1050v, and Presario 2100 Pavilion ze4200, nx9000, and Presario 2100 Evo N1010, and Presario 1100 F5771J Pavilion ze4100 F5761H User Repl No · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 5 No 5 No 5 5 No No 5 No 5 Keybd, JAPANESE SPSKEYBOARD-KO SPSKEYBOARD-LA SPSKEYBOARD-NO SPSKEYBOARD-PRC SPSKEYBOARD-PT SPSKEYBOARD-RU SPSKEYBOARD-SK Keybd, SPANISH No 5 5 5 No No No 5 No 5 No 5 No 5 5 No No 5 SPSKEYBOARD-SWE SPSKEYBOARD-SWI SPSKEYBOARD-TAI No 5 No 5 No 4-6 Replaceable Parts Service Manual Description 5 5 SPSKEYBOARD-THAI SPSKEYBOARD-TK Keybd, UK Part Number 317443-281 F464060930 317443-141 F464060931 317443-031 F464060932 317443-001 F576160906 F464060942 319426-001 319427-001 319477-001 319478-001 322998-001 322999-001 319479-001 Exchange Part Number Pavilion ze5x00, nx9010, nx9008, and Presario 2500 Pavilion ze4x00, Evo N1050v, and Presario 2100 Pavilion ze4200, nx9000, and Presario 2100 Evo N1010, and Presario 1100 F5771J Pavilion ze4100 F5761H User Repl No No · · · · · · · · · · · · · · · 5 No 5 Keybd, US ENGLISH Case, top­1F (Pavilion) Case, top­1F FF (gray/silver) SPS-CASE, TOP PAV SPS-CASE, TOP CPQ SPS-CASE, TOP 3F CPQ FF SPS-CASE, TOP 3F PAV FF SPS-CASE, TOP 3F CPQ DF SPS-CASE, TOP 3F PAV DF SPS-COVER, KEYBOARD W/SPEAKERS CPQ SPS-COVER, KEYBOARD W/SPEAKERS PAV FDD Assy w/cable 1F No 6 6 6 6 6 6 6 6 6 No No No No No No No No No · · · · · · · · · 6 323099-001 · No 7 F464060945 319448-001 · · · · No 7 SPS-DRV DSKT 144-MB 3F SPS-COVER DSKT DRV BLANK Cover, FDD­1F 320691-001 319511-001 · · · · · No No F576160901 319432-001 No Service Manual Replaceable Parts 4-7 Description 8 Heat sink­1F w/fan SPS-HEATSINK 3F W/2 FANS HEATSINK /FAN AMD, 53W Thermal pad, set Part Number F464060947 319456-001 319492-001 361380-001 F464060984 317438-001 F464060965 319431-001 Exchange Part Number Pavilion ze5x00, nx9010, nx9008, and Presario 2500 Pavilion ze4x00, Evo N1050v, and Presario 2100 Pavilion ze4200, nx9000, and Presario 2100 Evo N1010, and Presario 1100 F5771J Pavilion ze4100 F5761H User Repl No · · · · · · · · · 8 8 No No · · · · · · No 9 Kit, door­PCMCIA 1F Upper Door w/ Spring Lower Door w/ Spring SPS-DOOR PCMCIA SPS-PROC P4 24 GHz SPS-PROC P4 22 GHz SPS-PROC DT P4 22 GHz SPS-PROC 24 GHz 400 MHz FSB SPS-PROC 24 GHz 533 MHz FSB CPU, P4 20 GHz Northwood uFCPGA CPU, P4 19 GHz Northwood uFCPGA CPU, P4 18 GHz Northwood uFCPGA SPS-PROC DT P4 18 GHz CPU, P4 17 GHz Northwood UfcPGA SPS-PROC P4 16 GHz SPS-PROC C/20 GHz CPU, Cel-M 18 GHz Northwood uFCPGA No 9 10 10 10 10 319494-001 319462-001 319461-001 319482-001 323222-001 · · · · · · F553569205 F576569201 F553569202 No · · No No No No 10 323223-001 No 10 1822-0913 319460-001 1822-1060 319459-001 1822-0819 319458-001 319480-001 1822-0781 · · · · · · · · · · No 10 No 10 No 10 10 No F339869201 · · · · · · · · No 10 10 10 1822-0780 319457-001 319466-001 1822-1037 319465-001 F576569206 No No No · 4-8 Replaceable Parts Service Manual Description 10 CPU, Cel-M 17 GHz Northwood uFCPGA CPU, Cel-M 16 GHz Northwood uFCPGA CPU, Cel-M 15 GHz Northwood UfcPGA SPS-PROC ATH XP2000+ 167 GHz 45W SPS-PROC ATH XP1800+ 153 GHz 45W SPS-PROC ATH XP1700+ 146 GHz 45W PCA, motherboard­KE w/IEEE 1394 Socket, PCMICIA­1F Guide, HDD­1F Part Number 1822-0990 319464-001 Exchange Part Number F576569204 Pavilion ze5x00, nx9010, nx9008, and Presario 2500 Pavilion ze4x00, Evo N1050v, and Presario 2100 Pavilion ze4200, nx9000, and Presario 2100 Evo N1010, and Presario 1100 F5771J Pavilion ze4100 F5761H User Repl No · · · 10 1822-0989 319463-001 F576569203 · · · · No 10 1822-1024 F576569202 · · · · · · · · · · · · No 10 319849-001 No 10 319848-001 No 10 319850-001 No 11 F576160902 F464060967 F464060944 319455-001 No No No 11 PCA, motherboard­KE w/o IEEE 1394 Socket, PCMICIA­1F Guide, HDD­1F F576160903 F464060967 F464060944 319455-001 · · · · No No No 11 11 11 11 11 11 SPS-BD SYSTEM DF SPS-BD SYSTEM FF SPS-BD SYSTEM DF SPS-BD SYSTEM FF SPS-BD SYSTEM DF SPS-BD SYSTEM FF 319506-001 319507-001 319449-001 319450-001 319612-001 319613-001 · · · · · · No No No No No No Service Manual Replaceable Parts 4-9 Description 12 CD-ROM Assy­24x DVD Assy­8x Part Number F464060934 319420-001 F464060936 319421-001 F464060937 319422-001 319423-001 319419-001 F464060976 319467-001 F464060976 319467-001 F464060981 F464060980 F464060986 F464060987 319469-001 319470-001 317433-001 Exchange Part Number Pavilion ze5x00, nx9010, nx9008, and Presario 2500 Pavilion ze4x00, Evo N1050v, and Presario 2100 Pavilion ze4200, nx9000, and Presario 2100 Evo N1010, and Presario 1100 F5771J Pavilion ze4100 F5761H User Repl No · · · · · · · · · · · · · · · · · · · · · 12 No 12 CD-RW/DVD Combo Assy SPS-DVD+RW SPS-DRV CD-RW Antennas, Wireless R&L­1F Antennas, Wireless R&L­1F Case, bottom assy­FF XPHome Case, bottom assy­FF W2K/XPPro Case, bottom assy­FF W2K/XPPro Case, bottom assy­FF XPHome Base Enclosure FF Base Enclosure DF SPSENCLOSURE BASE DF SPSENCLOSURE BASE FF Cover, docking port Cover, modem port No 12 12 13 No No · · · · · · · · · · · · No 14 No 15 15 No No 15 · No 15 15 15 15 No No No · · · · · · · · · · · · · · · · · · · No 15 317432-001 No F464060966 319435-001 F464060960 319434-001 F464060901 319433-001 319489-001 Yes Yes 16 Cover, mem or Mini PCI­1F w/labels SPS-COVER MEM/MINI PC 3F Yes 16 Yes 4-10 Replaceable Parts Service Manual Description 17 Tray, HDD­1F Part Number F464060903 319417-001 319415-001 319416-001 320692-001 0950-4320 319414-001 0950-4288 Exchange Part Number Pavilion ze5x00, nx9010, nx9008, and Presario 2500 Pavilion ze4x00, Evo N1050v, and Presario 2100 Pavilion ze4200, nx9000, and Presario 2100 Evo N1010, and Presario 1100 F5771J Pavilion ze4100 F5761H User Repl Yes · · · · · · · · · · · · · · · 18 18 18 18 SPS-DRV HD 60 G (4200rpm) SPS-DRV HD 60 G (5400 rpm) SPS-DRV HD 80 G (4200 rpm) HDD-40 GB 95mm, IBM ATA100 FDB HDD-40 GB 95mm, Toshiba ATA100 HDD-30 GB 95mm, Hitachi ATA100 HDD-30 GB 95mm, IBM (diablo) ATA100 HDD-30 GB 95mm, IBM ATA100 FDB (Cascade) HDD-30 GB 95mm, TITAN Toshiba ATA100 (TITAN) HDD-30 GB 95mm, Toshiba ATA100 HDD-20 GB 95mm, Hitachi ATA100 HDD-20 GB 95mm, IBM ATA100 FDB HDD-20 GB 95mm, TOSH ATA100 FDB Kit, cable­1F Yes Yes Yes · · · · · · Yes 18 Yes 18 0950-4168 Yes 18 0950-4162 319413-001 0950-4319 · · · · · Yes 18 Yes 18 0950-4360 · · Yes 18 0950-4176 · · · · · · · · · · · · · · · · · · Yes 18 0950-4193 319412-001 0950-4318 Yes 18 Yes 18 0950-4287 Yes F464060974 319424-001 F464060970 319446-001 F576160907 No Kit, display screw cover Kit, display screw cover­Pavilion Yes · Yes Service Manual Replaceable Parts 4-11 Description 19 Kit, rubber foot and screw plug SPS PANEL IR 3F W/IR & BUTTON SPS PANEL IR 3F W/IR & W/O BTN Panel, IR­1F w/o IR & w/ button Panel, IR­1F w/o IR & w/o button Panel, IR­1F w/IR & w/button Panel, IR­1F w/IR & w/o button SPS-BD IR 3F PCA, IR ­ 1F w/o IR PCA, IR­1F w/IR Battery, Li ion 44AHr 8 Cell Li ion SPS-FAN 3F SMALL SPS-CABLE KIT 3F SPS-BD RJ45/1394 SPS-BD RJ45 Shield, ESD 3F SPS-TRAY, HDD, 3F Cover, docking port HP/Compaq SPS-BD AUDIO CONTROL 3F Part Number F464060969 317437-001 319502-001 Exchange Part Number Pavilion ze5x00, nx9010, nx9008, and Presario 2500 Pavilion ze4x00, Evo N1050v, and Presario 2100 Pavilion ze4200, nx9000, and Presario 2100 Evo N1010, and Presario 1100 F5771J Pavilion ze4100 F5761H User Repl Yes · · · · · · · · · · · · · · · · · · · · · · · 20 No 20 319503-001 No 20 F464060948 317439-001 F464060949 317440-001 F464060950 317441-001 F464060951 317442-001 319505-001 F464060964 319454-001 F464060946 319453-001 F480960901 319411-001 319490-001 319493-001 319512-001 319513-001 323187-001 335941-001 F464160905 319504-001 · · · · · · · · · · · · No 20 No 20 No 20 No 21 21 No · · · · · · · · · No 21 No 22 Yes 23 24 25 25 26 27 28 29 No No No No No No · · Yes No 4-12 Replaceable Parts Service Manual Table 4-2 Accessory Replaceable Parts Pavilion ze5x00, nx9010, nx9008, Part Number F4694-60901 317434-001 F4695-60901 317435-001 F4696-60901 317436-001 F4600-60901 F4809-60901 319411-001 F4640-60978 319468-051 F4640-60977 319468-002 8120-6312 317444-011 8120-6314 8120-6316 317444-291 8120-8699 317444-031 8120-6313 317444-001 F4808-60901 317448-001 F4808-60902 Pavilion ze4x00, nx9005, Evo N1050v, and Presario 2100 Pavilion ze4200, nx9000, and Presario 2100 Evo N1010v, Presario 1100 F5771J Pavilion ze4100 H5761H User Repl Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes Description 128MB DDR266B 256MB DDR266B 512MB DDR266B AC-Adapter-Ultraslim Delta 75W s/PFC Battery, Li ion 44AHr 8 Cell Li ion Card, Mini PCI80211B France Card, Mini PCI80211B worldwide Cord, Pwr, Austr ABG (2w) Cord, Pwr, Europe ABB (2w) Cord, Pwr, Japan ABJ (2w) Cord, Pwr, UK (EPSR) For Hong Kong (2w) Cord, Pwr, US ABA (2w) Port Replicator Assy Simple Port Replicator HP/Compaq and Presario 2500 · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · Yes Yes Yes Yes Service Manual Replaceable Parts 4-13 Table 4-3 Part Number Reference Pavilion ze4x00, nx9005, Evo N1050v and Presario 2100 · Part Description 0950-4162 0950-4168 0950-4176 0950-4193 0950-4287 0950-4288 0950-4318 0950-4319 0950-4320 0950-4360 Exchange Part Number F2072-69115 F3257-69106 F3257-69103 F3257-69105 F3476-69002 F3378-69102 F3257-69501 F3414-69500 F3428-69500 F3414-69501 Description HDD-300GB 9. 5mm, IBM (diablo) ATA100 HDD-30GB 9. 5mm, Hitachi ATA100 HDD-30GB 9. 5mm, Toshiba ATA100 HDD-20GB 9. 5mm, Hitachi ATA100 HDD-20GB 9. 5mm, TOSH ATA100 FDB HDD-40GB 9. 5mm, Toshiba ATA100 HDD-20GB 9. 5mm, IBM ATA100 FDB HDD-300GB 9. 5mm, IBM ATA100 FDB (Cascade) HDD-40. 0GB 9. 5mm, IBM ATA100 FDB HDD-30GB 9. 5mm, TITAN Toshiba ATA100 (TITAN) SPS-PROC P4 1. 6 GHz Pavilion ze5x00, nx9010, nx9008 and Presario 2500 · Pavilion ze4200, nx9000 and Presario 2100 · Evo N1010 v and Presari o 1100 F5771J · · · Pavilion ze4100 H5761H · · · · · · User Repl Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes · · · · · · · · · · · · · · · 1822-0780 1822-0781 1822-0819 1822-0913 1822-0989 1822-0990 1822-1024 1822-1037 1822-1060 7121-7525 8120-6312 8120-6313 8120-6314 8120-6316 8120-8373 8120-8699 317432-001 F3398-69201 F5535-69202 F5535-69205 F5765-69203 F5765-69204 F5765-69202 F5765-69206 F5765-69201 No · No No No No No No No No No Yes Yes Yes Yes Yes · · Yes No CPU, P4 1. 7 GHz Northwood uFCPGA CPU, P4 1. 8 GHz Northwood uFCPGA CPU, P4 2. 0 GHz Northwood uFCPGA CPU, Cel-M 1. 6 GHz Northwood uFCPGA CPU, Cel-M 1. 7 GHz Northwood uFCPGA CPU, Cel-M 1. 5 GHz Northwood uFCPGA CPU, Cel-M 1. 8 GHz Northwood uFCPGA CPU, P4 1. 9 GHz Northwood uFCPGA Overlay, serial label Cord, Pwr, Austr ABG (2w) Cord, Pwr, US ABA (2w) Cord, Pwr, Europe ABB (2w) Cord, Pwr, Japan ABJ (2w) SPS-CORD AC PWR 2 WIRE-PRC Cord, Pwr, UK (EPSR) For Hong Kong (2w) SPS-ENCLOSURE BASE FF · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 4-14 Replaceable Parts Service Manual Part Description 317433-001 317434-001 317435-001 317436-001 317437-001 317438-001 317439-001 317440-001 317441-001 317442-001 317443-001 317443-002 317443-021 317443-031 317443-041 317443-051 317443-061 317443-071 317443-081 317443-091 317443-101 317443-111 317443-121 317443-131 317443-141 317443-151 317443-161 317443-171 317443-181 317443-201 317443-211 317443-221 317443-231 Exchange Part Number Description SPS-ENCLOSURE BASE DF 128MB DDR266B 256MB DDR266B 512MB DDR266B Kit, rubber foot and screw plug Thermal pad, set Panel, IR­1F w/o IR & w/button Panel, IR­1F w/o IR & w/o button Panel, IR­1F w/IR & w/button Panel, IR­1F w/IR & w/o button Keybd, US ENGLISH SPS-KEYBOARD-INTL SPS-KEYBOARD-EUR Keybd, UK Keybd, GERMAN Keybd, FRENCH Keybd, ITALIAN Keybd, SPANISH SPS-KEYBOARD-DEN SPS-KEYBOARD-NO SPS-KEYBOARD-SWE SPS-KEYBOARD-SWI SPS-KEYBOARD-FC SPS-KEYBOARD-PT SPS-KEYBOARD-TK SPS-KEYBOARD-GRK SPS-KEYBOARD-LA SPS-KEYBOARD-AR SPS-KEYBOARD-BEL SPS-KEYBOARD-BR SPS-KEYBOARD-HUN SPS-KEYBOARD-CZ SPS-KEYBOARD-SK Pavilion ze5x00, nx9010, nx9008 and Presario 2500 Pavilion ze4x00, nx9005, Evo N1050v and Presario 2100 · · · · · · · · · · Pavilion ze4200, nx9000 and Presario 2100 · · · · · · · · · · · · Evo N1010 v and Presari o 1100 F5771J Pavilion ze4100 H5761H User Repl No Yes · · · Yes Yes Yes No No No No No No No No · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · No No · · · No No No No No No No No No No No No No No No No No No Service Manual Replaceable Parts 4-15 Part Description 317443-251 317443-281 317443-291 317443-AA1 317443-AB1 317443-AD1 317443-BB1 317443-DD1 317444-001 317444-002 317444-011 317444-031 317444-061 317444-101 317444-111 317444-291 317444-AA1 317444-AB1 317444-AD1 Exchange Part Number Description SPS-KEYBOARD-RU SPS-KEYBOARD-THAI Keybd, JAPANESE SPS-KEYBOARD-PRC SPS-KEYBOARD-TAI SPS-KEYBOARD-KO SPS-KEYBOARD-HE SPS-KEYBOARD-ICL Cord, Pwr, US ABA (2w) SPS-CORD AC PWR 2 WIRE-INTL Cord, Pwr, Austr ABG (2w) Cord, Pwr, UK (EPSR) For Hong Kong (2w) SPS-CORD AC PWR 2 WIRE-IT SPS-CORD AC PWR 2 WIRE-SWE SPS-CORD AC PWR 2 WIRE-SWI Cord, Pwr, Japan ABJ (2w) SPS-CORD AC PWR 2 WIRE-PRC SPS-CORD AC PWR 2 WIRE-TAI SPS-CORD AC PWR 2 WIRE-KO Pavilion ze5x00, nx9010, nx9008 and Presario 2500 Pavilion ze4x00, nx9005, Evo N1050v and Presario 2100 · · · · · · · · · · Pavilion ze4200, nx9000 and Presario 2100 · · · · · · · · · · · · · · · · · · · Evo N1010 v and Presari o 1100 F5771J Pavilion ze4100 H5761H User Repl No No · No No No No No No · Yes Yes · · · · · · · · · · · · · · Yes Yes Yes Yes Yes · Yes Yes Yes Yes 4-16 Replaceable Parts Service Manual Part Description 317445-001 317446-001 317447-001 317448-001 317473-001 319411-001 319412-001 319413-001 319414-001 319415-001 319416-001 319417-001 319418-001 319419-001 319420-001 319421-001 319422-001 319423-001 319424-001 319425-001 319426-001 319427-001 319428-001 319429-001 319430-001 319431-001 319432-001 319433-001 319434-001 319435-001 Exchange Part Number Description PCA, switchboard w/cable 1F Pavilion SPS-BD switch w/ cable 1F CPQ SPS-LABEL NAME SET Port Replicator Assy Kit, rubber foot and screw plug Battery, Li ion 44AHr 8 Cell Li ion HDD-20GB 95mm, Hitachi ATA100 HDD-30. 0GB 9. 5mm, IBM (diablo) ATA100 HDD-40 GB 9. 5mm, IBM ATA100 FDB SPS-DRV HD 60 G (4200rpm) SPS-DRV HD 60 G (5400 rpm) Tray, HDD­1F Guide, HDD­1F SPS-DRV CD-RW CD-ROM Assy­24X DVD Assy­8x CD-RW/DVD Combo ASSY SPS-DVD+RW Kit, cable­1F Kit, screw SPS-CASE, TOP PAV SPS-CASE, TOP CPQ Cover, Keyboard­1F Pavilion SPS-COVER KEYBOARD EVO Cover, Keyboard­1F Compaq Kit, door­PCMCIA Cover, FDD­1F Cover, mem or Mini PCI­1F w/labels Cover, modem port Cover, docking port Pavilion ze5x00, nx9010, nx9008 and Presario 2500 Pavilion ze4x00, nx9005, Evo N1050v and Presario 2100 · · · · · Pavilion ze4200, nx9000 and Presario 2100 · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · Evo N1010 v and Presari o 1100 F5771J Pavilion ze4100 H5761H · User Repl No No Yes · · Yes Yes Yes · · · · · · · · · · · · · · · · · · Yes Yes Yes Yes Yes · · · · Yes No No · · · · · · · · · · · · · · · · · · · · · · · · · No No No · · · · No Yes No No · No No · · · · · · · · · No No No Yes Yes Yes Service Manual Replaceable Parts 4-17 Part Description 19436-001 319437-001 319438-001 319439-001 319440-001 319441-001 319445-001 319446-001 319447-001 319448-001 319449-001 319450-001 319453-001 319454-001 319455-001 319456-001 319457-001 319458-001 319459-001 319460-001 319461-001 319462-001 319463-001 319464-001 319465-001 319466-001 319467-001 319468-002 319468-051 319469-001 Exchange Part Number Description Display 14. 1-inch XGA­ Pavilion KE Display 15. 0-inch XGA­ Pavilion KE Display 15. 0-inch SXGA+­ Pavilion KE SPS-DSPLY PANEL 15. 0inch SXGA CPQ SPS-DSPLY PANEL 15. 0inch XGA CPQ SPS-DSPLY PANEL 14. 1inch XGA CPQ SPS-BD INVERTER Kit, display screw cover Speaker assy­F FDD Assy w/cable­1F SPS-BD SYSTEM DF SPS-BD SYSTEM FF PCA, IR­1F w/IR PCA, IR­1F w/o IR Socket, PCMCIA­1F Heat sink­1F w/fan SPS-PROC P4 1. 6 GHz CPU, P4 1. 8 GHz Northwood uFCPGA CPU, P4 1. 9 GHz Northwood uFCPGA CPU, P4 2. 0 GHz Northwood uFCPGA SPS-PROC P4 2. GHz SPS-PROC P4 2. 4 GHz CPU, Cel-M 1. 6 GHz Northwood uFCPGA CPU, Cel-M 1. 7 GHz Northwood uFCPGA CPU, Cel-M 1. 8 GHz Northwood uFCPGA SPS-PROC C/2. 0 GHz Antennas, Wireless R&L­1F Card, Mini PCI-802. 11B worldwide Card, Mini PCI-802. 11B France Base Enclosure FF Pavilion ze5x00, nx9010, nx9008 and Presario 2500 Pavilion ze4x00, nx9005, Evo N1050v and Presario 2100 · · · · · · · · · · · · · · · · · · · · · · · · · · · Pavilion ze4200, nx9000 and Presario 2100 · · · · · · · · · · Evo N1010 v and Presari o 1100 F5771J Pavilion ze4100 H5761H · · · User Repl No No No No No No No · · · · Yes No No No No · · · · · · · · · · · · · · · · · · · · · · · · · No No No No No · · · No No No No No · · · No No No No · · · · · · · No Yes Yes No · · · · · 4-18 Replaceable Parts Service Manual Part Description 319470-001 319477-001 319478-001 319479-001 319480-001 319482-001 319483-001 319484-001 Exchange Part Number Description Base Enclosure DF SPS-CASE TOP 3F CPQ FF SPS-CASE, TOP 3F PAV FF SPS-COVER, KEYBOARD W/SPEAKERS CPQ SPS-PROC DT P4 1. 8 GHZ SPS-PROC DT P4 2. 2 GHZ SPS-DSPLY PANEL 14. 1inch XGA PAV SPS-DSPLY PANEL 15. 0inch XGA PAV SPS-DSPLY PANEL 15. 0inch SXGA PAV SPS-DSPLY PANEL14. 1-inch SGA PRES SPS-DSPLY PANEL 15. 0inch SGA PRES SPS-DSPLY PANEL 15. 0inch SXGA PRES SPS-COVER MEM/MINI PC 3F SPS-FAN 3F SMALL SPS-HEATSINK 3F W/2 FANS SPS-CABLE KIT 3F SPS-DOOR PCMCIA SPS PANEL IR 3F W/IR & BUTTON SPS PANEL IR 3F W/IR & W/O BTN SPS-BD AUDIO CONTROL 3F SPS-BD IR 3F SPS-BD SYSTEM DF SPS-BD SYSTEM FF SPS-COVER DSKT DRV BLANK SPS-BD RJ45/1394 SPS-BD RJ45 SPS-BD SYSTEM DF SPS-BD SYSTEM FF Pavilion ze5x00, nx9010, nx9008 and Presario 2500 · · · · · · · · Pavilion ze4x00, nx9005, Evo N1050v and Presario 2100 Pavilion ze4200, nx9000 and Presario 2100 Evo N1010 v and Presari o 1100 F5771J Pavilion ze4100 H5761H User Repl No No No No No No No No 319485-001 · No 319486-001 319487-001 · · No No 319488-001 · No 319489-001 319490-001 319492-001 319493-001 319494-001 319502-001 319503-001 319504-001 319505-001 319506-001 319507-001 319511-001 319512-001 319513-001 319612-011 319613-001 · · · · · · · · · · · · · · · · · · · Yes No No No No No No No No No No No No No No No Service Manual Replaceable Parts 4-19 Part Description 319848-001 319849-001 319850-001 320691-001 320692-001 322998-001 322998-001 323099-001 323222-001 323223-001 F4600-60901 F4640-60901 Exchange Part Number Description SPS-PROC ATH XP1800+ 1. 53-GHz 45W SPS-PROC ATH XP2000+ 1. 67-GHz 45W SPS-PROC ATH XP1700+ 1. 46-GHz 45W SPS-DRV DSKT 144 MB 3F SPS-DRV HD 80 G (4200 rpm) SPS-CASE TOP 3F CPQ DF SPS-CASE, TOP 3F PAV DF SPS-COVER, KEYBOARD W/SPEAKERS PAV SPS-PROC 24 GHz 400 MHz FSB SPS-PROC 24 GHz 533 MHz FSB AC-Adapter-Ultraslim Delta 75W s/PFC Cover, mem or Mini PCI­1F w/ labels Tray, HDD­1F Speaker assy­1F SPS-KEYBOARD-AR SPS-KEYBOARD-BEL SPS-KEYBOARD-CZ SPS-KEYBOARD-DEN Keybd, FRENCH SPS-KEYBOARD-FC Keybd, GERMAN SPS-KEYBOARD-GRK SPS-KEYBOARD-HE SPS-KEYBOARD-HUN SPS-KEYBOARD-INTL Keybd, ITALIAN Keybd, JAPANESE SPS-KEYBOARD-NO SPS-KEYBOARD-PT SPS-KEYBOARD-RU Keybd, SPANISH SPS-KEYBOARD-SWE Pavilion ze5x00, nx9010, nx9008 and Presario 2500 Pavilion ze4x00, nx9005, Evo N1050v and Presario 2100 Pavilion ze4200, nx9000 and Presario 2100 · · · Evo N1010 v and Presari o 1100 F5771J Pavilion ze4100 H5761H User Repl No No No No · · · · · · · · · · · · · · · Yes No No No No No Yes Yes F4640-60903 F4640-60908 F4640-60909 F4640-60910 F4640-60911 F4640-60912 F4640-60913 F4640-60914 F4640-60915 F4640-60916 F4640-60917 F4640-60918 F4640-60920 F4640-60921 F4640-60922 F4640-60923 F4640-60924 F4640-60925 F4640-60926 F4640-60927 · · · · · · · · · · · · · · · Yes No No No No No · · · · · · · · · · · · · · · · · · · · · · · · · · · · No No No No No No No No No No No No No No 4-20 Replaceable Parts Service Manual Part Description F4640-60928 F4640-60929 F4640-60930 F4640-60931 F4640-60932 F4640-60933 F4640-60934 F4640-60936 F4640-60937 F4640-60942 F4640-60944 F4640-60945 F4640-60946 F4640-60947 F4640-60948 F4640-60949 F4640-60950 F4640-60951 F4640-60960 F4640-60964 F4640-60965 F4640-60966 F4640-60967 F4640-60969 F4640-60970 F4640-60974 F4640-60975 F4640-60976 F4640-60977 F4640-60978 F4640-60980 F4640-60981 Exchange Part Number Description SPS-KEYBOARD-SWI SPS-KEYBOARD-PRC SPS-KEYBOARD-TK Keybd, UK Keybd, US ENGLISH PCA, switchboard w/cable­ 1F CD-ROM Assy­24X DVD Assy­8x Pavilion ze5x00, nx9010, nx9008 and Presario 2500 Pavilion ze4x00, nx9005, Evo N1050v and Presario 2100 · · · Pavilion ze4200, nx9000 and Presario 2100 · · · · · Evo N1010 v and Presari o 1100 F5771J Pavilion ze4100 H5761H User Repl No No No · · · · · · · No No No · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · No No No No No No No No No No No No Yes No No Yes No Yes Yes No Yes No Yes Yes No No F4640-69037 CD-RW/DVD Combo ASSY Case, top­1F (gray/silver) Guide, HDD­1F FDD Assy w/cable­1F PCA, IR­1F w/IR Heat sink­1F w/fan Panel, IR­1F w/o IR & w/button Panel, IR­1F w/o IR & w/o button Panel, IR­1F w/IR & w/button Panel, IR­1F w/IR & w/o button Cover, modem port PCA, IR­1F w/o IR Kit, door­PCMCIA Cover, docking port Socket, PCMCIA­1F Kit, rubber foot and screw plug Kit, display screw cover Kit, cable­1F Kit, screw Antennas, Wireless R&L­1F Card, Mini PCI-802. 11B worldwide Card, Mini PCI-8021. 1B France F4640-69080 F4640-69081 Case, bottom assy­ W2K/XPPro Case, bottom assy­XPHome Service Manual Replaceable Parts 4-21 Part Description F4640-60984 F4640-60986 F4640-60987 F4641-60905 F4641-60906 F4694-60901 F4695-60901 F4696-60901 F4808-60901 F4808-60902 F4809-60901 F5761-12001 F5761-12003 F5761-12006 F5761-60901 F5761-60902 F5761-60903 F5761-60904 F5761-60905 F5761-60906 F5761-60907 F5761-60910 F5761-60911 F5761-60912 F5761-60913 F5771-60901 F5771-60902 F5771-60903 F5771-60904 F5781-12004 Exchange Part Number Description Thermal pad, set Pavilion ze5x00, nx9010, nx9008 and Presario 2500 Pavilion ze4x00, nx9005, Evo N1050v and Presario 2100 · Pavilion ze4200, nx9000 and Presario 2100 · Evo N1010 v and Presari o 1100 F5771J · · · · · Pavilion ze4100 H5761H · · User Repl No No No F4640-69086 F4640-69087 Case, bottom assy­w/1394 W2K/XPPro Case, bottom assy­w/1394 XPHome Cover, docking port HP/Compaq Training set, Series 02-B 128MB DDR266B 256MB DDR266B 512MB DDR266B Port Replicator Assy Simple Port Replicator HP/Compaq Battery, Li ion 44AHr 8 Cell Li ion CD, Rec XP Home NA ENG CD, Rec XP Home AUS EN CD, Rec XP Home NA ENG Cover, FDD­1F · · · · · · · · · · · · · · · · Yes No Yes Yes Yes Yes Yes Yes No No No No No No No No No No No No No Yes No No No No No · · · · · · · · · · · · F5761-69002 F5761-69003 PCA, motherboard­KE w/IEEE 1394 PCA, motherboard­KE w/o IEEE 1394 Cover, Keyboard­1F Pavilion PCA, switchboard w/cable­ 1F Pavilion Case, top­1F (Pavilion) Kit, display screw cover­ Pavilion · · · · · · · · · · · · F5761-69010 F5761-69011 F5761-69012 Display 14. 1-inch XGA­ Pavilion KE Display 15. 0-inch XGA­ Pavilion KE Display 15. 0-inch SXGA+­ Pavilion KE Label, Name set­KE · · · · · · · · · · · · · · F5771-69001 F5771-69002 F5771-69003 Display 14. 1-inch XGA­ (Compaq) Display 15. 0-inch XGA­ (Compaq) Display 15. 0-inch SXGA+(Compaq) Cover, Keyboard­1F Compaq CD, Rec XP Home UK ENG · · · · 4-22 Replaceable Parts Service Manual 5 Reference Information This chapter includes the following reference information: · · Password removal policy Display quality statement Service Manual Reference Information 5-1 Password Removal Policy If the user forgets the system password, the user calls Technical Support to determine the proper removal procedure The user must provide proof of ownership and the notebook must be operated during the procedure. [. . . ]