User manual HUSQVARNA 532441748

[. . . ] 07002 917. 240461 (YTH20K46) Owner's Manual Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. 532 44 17-48 Rev. 1 SAFETY RULES Safe Operation Practices for Ride-On Mowers DANGER: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. WARNING: In order to prevent accidental starting when setting up, transporting, adjusting or making repairs, always disconnect spark plug wire and place wire where it cannot contact spark plug. [. . . ] Adding or checking level of electrolyte is not necessary. TO CLEAN BATTERY AND TERMINALS Corrosion and dirt on the battery and terminals can cause the battery to “leak” power. • Disconnect BLACK battery cable first then RED battery cable and remove battery from tractor. • Rinse the battery with plain water and dry. • Clean terminals and battery cable ends with wire brush until bright. • Coat terminals with grease or petroleum jelly. • Reinstall battery (See “REPLACING BATTERY" in the SERVICE AND ADJUSTMENTS section of this manual). 02828 ROS "ON" POSITION ENGINE "ON" POSITION (NORMAL OPERATING) Fig. 14 15 MAINTENANCE V-BELTS Check V-belts for deterioration and wear after 100 hours of operation and replace if necessary. Replace belts if they begin to slip from wear. CLOSED AND LOCKED POSITION YELLOW CAP OIL DRAIN VALVE 02 46 3 TRANSAXLE COOLING The transmission fan and cooling fins should be kept clean to assure proper cooling. Do not attempt to clean fan or transmission while engine is running or while the transmission is hot. To prevent possible damage to seals, do not use high pressure water or steam to clean transaxle. • Inspect cooling fan to be sure fan blades are intact and clean. • Inspect cooling fins for dirt, grass clippings and other materials. To prevent damage to seals, do not use compressed air or high pressure sprayer to clean cooling fins. DRAIN TUBE • • • • • TRANSAXLE PUMP FLUID The transaxle was sealed at the factory and fluid maintenance is not required for the life of the transaxle. Should the transaxle ever leak or require servicing, contact your nearest authorized service center/department. ENGINE LUBRICATION Only use high quality detergent oil rated with API service classification SG-SL. Select the oil’s SAE viscosity grade according to your expected operating temperature. SAE VISCOSITY GRADES 10W30 5W-30 F C -30 -20 -20 0 -10 30 32 0 40 10 60 20 80 30 100 40 Fig. 16 To open, pull out on the drain valve. After oil has drained completely, close and lock the drain valve by pushing inward and turning clockwise until the pin is in the locked position as shown. Remove the drain tube and replace the cap onto to the bottom fitting of the drain valve. Refill engine with oil through oil fill dipstick tube. For approximate capacity see “PRODUCT SPECIFICATIONS” section of this manual. Use gauge on oil fill cap/dipstick for checking level. [. . . ] SV600-3229 HEAD/VALVE/BREATHER 4-20-19 TRACTOR - - MODEL NUMBER 917. 240461, PRODUCT NO. YTH20K46 20 318 10-S 20 318 01-S 20 318 03-S 20 318 05-S 20 318 07-S 20 318 11-S 20 318 12-S 20 318 14-S 20 318 15-S 20 086 02-S 20 017 01-S 20 017 02-S 12 468 05-S 28 032 01-S 20 032 10-S 20 089 03-S 20 173 01-S 20 062 01-S 20 146 03-S 20 086 03-S 20 072 08-S 20 186 01-S 20 599 02-S 20 599 03-S 20 599 04-S 20 326 01-S 20 326 20-S 12 468 03-S 25 468 09-S 20 599 01-S 20 086 04-S 20 841 01-S 20 841 02-S 20 016 01-S 20 016 02-S 20 411 02-S 20 411 04-S 20 411 05-S 20 089 03-S 20 173 01-S 20 599 01-S 20 086 04-S 20 062 01-S 20 146 03-S 20 086 03-S 20 072 08-S 20 599 02-S 20 599 03-S 20 186 01-S 20 599 04-S 20 086 04-S 20 041 04-S 20 041 13-S M-645020-S 20 162 02-S 20 096 03-S 20 096 06-S 20 096 07-S 20 096 14-S 12 086 14-S 25 086 125-S 25 086 362-S 20 146 02-S 20 146 04-S 20 146 05-S 20 157 01-S IGNITION/ELECTRICAL 5-20-41 20 366 01-S 20 404 01-S 20 025 05-S 20 025 33-S 20 025 35-S 20 025 40-S 24 025 09-S M-545020-S 20 584 01-S 20 584 03-S 20 584 04-S 20 123 01-S 231285-S M-561025-S X-42-15-S 25 340 02-S 25 340 04-S 20 086 22-S 20 086 17-S 20 154 02-S 25 154 08-S M-548025-S 20 154 04-S 20 154 03-S 237878-S 20 085 01-S 20 132 02-S 12 132 02-S 25 132 12-S 25 132 14-S 41 403 09-S 41 403 10-S 25 155 41-S 236602-S M-545020-S 47 KOHL ENGINE - MODEL NO. SV600-3229 BLOWER HOUSING & BAFFLES 6-20-7 TRACTOR - - MODEL NUMBER 917. 240461, PRODUCT NO. YTH20K46 STARTING SYSTEM 7-20-1 20 086 06-S 25 100 31-S 20 098 01-S 20 098 06-S 12 100 07-S 20 755 11-S 24 086 41-S 20 027 02-S 20 027 03-S 20 027 06-S 20 027 07-S 20 027 01-S 25 100 31-S 20 755 12-S 20 314 06-S 20 086 06-S 20 098 05-S 20 098 08-S 12 100 07-S 12 221 02-S M-645016-S 20 227 01-S 20 211 02-S 20 063 03-S 48 KOHL ENGINE - MODEL NO. [. . . ]