User manual HYOSUNG GV650

[. . . ] This manual should be considered a permanent part of the motorcycle and should remain with the motorcycle when resold or otherwise transferred to a new owner or operator. The manual contains important safety information and instructions which should be read carefully before operating the motorcycle. 1 FOREWORD THANK YOU for choosing Hyosung motorcycle. We at Hyosung have designed, tested and produced this motorcycle using the most modern technology available to provide you with much happy, enjoyable, safe riding. Motorcycling is one of the most exhilarating sports and insure your riding enjoyment, you should become thoroughly familiar with the information presented in this Owner's Manual before riding the motorcycle. [. . . ] The coolant should be kept between the "F" "L" (FULL) and (LOW) level lines in the reservoir tank at all times. Inspect the level every time before riding while the motorcycle vertically. If the coolant is found lower "L"level line, add properly mixed than the coolant in the following way : If the reservoir tank is emptied, pour the engine coolant to the reservoir tank and radiator. Remove the filler cap and add properly mixed coolant through the filler hole until it "F" line. reaches the Refer to the FUEL, ENGINE OIL AND COOLANT RECOMMENDATION section (12 page). 38 WARNING Engine coolant is harmful or fatal if swallowed or inhaled. Do not drink anti-freeze or coolant solution. Immediately contact a poison control center or a physician. Avoid inhaling mist or hot vapors ; if inhaled, remove to fresh air. If coolant gets in eyes, flush eyes with water and seek medical attention. Keep out of the reach of children and aminals. OPEN THE RADIATOR CAP Remove the right front side cover to operate the radiator cap . To disassemble the right front side cover , remove the two mounting bolt . WARNING You can be injured by scalding fluid or steam if you open the radiator cap when the engine is hot. After the engine cools, wrap a thick cloth around cap and carefully remove the cap by turning it a quarter to allow pressure to escape and then turn the cap all the way off. NOTE Adding only water will dilute the engine coolant and reduce its effectiveness. Add 50 : 50 mixture of engine coolant and water. CHANGING THE COOLANT Change the coolant every two years. NOTE About 1. 6 of coolant will be required when filling the radiator and reservoir tank. 39 RIDING TIPS STARTING THE ENGINE Necessary attempt before start the engine : 1. Inspect every day once before riding the motorcycle. The ignition switch is in the"ON" position. The engine stop switch is in the position. Moving the side stand to the upper position. Pull the clutch lever. When the engine is cold : 1. Turn the carburetor choke lever all the way toward you. Close the throttle grip and push the starter switch. Immediately after the engine starts, return the choke lever halfway and warm up the engine. Return the choke lever all the way back to its disengaged position. When the engine is warm : 1. Push the starter switch. CAUTION Operation of the carburetor choke system is not necessary when the engine is warm. WARNING The is equipped with the side stand ignition interlock system. [. . . ] Check the engine idle speed. CAUTION When any trouble occurs, the best way is to consult your Hyosung dealer for repairs. WHEN KEEPING FOR LONG PERIOD 1. Supply the enough fuel in the fuel tank. Do drain wholly the fuel in the carburetor. Remove the battery from the motorcycle. WARNING Performing the spark test improperly can cause a high voltage electrical shock or an explosion. [. . . ]