User manual KAWAI Q-80EX

[. . . ] 3 CONSERVATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 SYMBOLS USED. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 EQUIPMENT FEATURES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 USE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ] The card K convers setting K Convrs lt/h 180 Move to the next page with the key; access the modification of the key. The card therefore liters/hour conversion parameter with the and keys and confirm with the indicates "Data saved" Time setting Move to the next page with the with the key; modify the "filter hours" parameter and keys and Funz h 0070 key. Modify the value with the confirm with the key. The card therefore indicates "Data saved" Set Language Set English Move to the next page with the key the key with the key ; modify the language parameter with and and confirm . The card therefore indicateds "Data saved". 5 5. 1 ROUTINE MAINTENANCE MAINTENANCE PERSONNEL QUALIFICATIONS Personnel in charge of Maintenance must have the requisites indicated in the following and be familiar with this manual and all information concerning safety: Sufficient level of general and technical knowledge in order to understand the contents of this manual. Knowledge of the main hygienic, accident-prevention and technological regulations. Complete knowledge of the machine as well as electrical and hydraulic problems that can arise where the machine is installed. 5. 2 MAINTENANCE PERSONNEL TASKS The routine maintenance program described in this paragraph must be carried out according to the schedule indicated in order to keep the machine running efficiently and to guarantee the quality of the water treatment. The operations indicated in the following must be carried out by qualified personnel according to the instructions in this manual and only using original spare parts. Maintenance performed must be documented and signed by the technician in charge in the proper space on the maintenance register in the ATTACHMENT. - 13 - It is advisable to carry out routine maintenance at least once every 6 months, even if the filters have not run out. CONTROL FREQUENCY Preload expansion tank 6 MONTHS Visual control of the integrity and state of o conservation Machine 10000 liter General cleaning (*) Check running Filters with active carbon Replacement (*)Particular water conditions can require more frequent maintenance. Clean the male and female connectors from possible oxidation. Tighten the connector with pliers and reassembly. - 15 - 5. 7 CLEANING SOLENOID VALVES FILTER Close the inlet water valve. Open the faucet to remove the pressure in the feed pipe. Turn off the machine and remove the ¾" fitting from the solenoid valve. Using pliers, gently pull the solenoid valve filter. Clean the filter with tap water and/or compressed air. 5. 8 MACHINE SANITATION Perform the sanitation of the machine at each filter replacement, and at intervals not exceeding 6 months. Perform sanitation also after long not-use periods of the machine. All sanitation operations must be performed by qualified personnel. Be careful in the use and dosage of chemicals. Use protective clothing to the skin, hands and eyes as shown in the safety data sheet of chemicals used. Close the mixing valve and fill a tank with 10 liters of permeate water. [. . . ] Deitar este aparelho em um centro de recolha ou de reciclagem segundo a lei local e nacional. O consumidor tem uma importante responsabilidade na redução do lixo, preparando a reciclagem dos instrumentos eléctrico/electrónicos. A reciclagem previne a dispersão de materiais perigosos nos lixos minicipais. O símbolo da barra no barril lembra ao utilizador de não jogar este producto como um lixo municipal não classificado. [. . . ]