User manual KOHLER K361 SERVICE MANUAL

[. . . ] 10 Angle of Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 Cooling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 Maintenance Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Maintenance Schedule . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ] 19 Transport . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 Major Repair. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Parts Ordering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Engine Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 Emission Control System Warranty . . . . . . . . . 22-23 Safety Precautions WARNING can cause severe CAUTION will can cause minor NOTE For Your Safety!These precautions should be followed at all times. Failure to follow these precautions could result in injury to yourself and others. 3 Safety Precautions (Continued) WARNING WARNING WARNING Hot Parts can cause severe burns. Lethal Exhaust Gases! its vapors can explode if ignited. Store gasoline only in approved containers, in well ventilated, unoccupied buildings, the fuel tank while the engine is hot or running, since spilled fuel could ignite if it comes in contact with hot parts the engine near spilled fuel. Engine exhaust gases contain poisonous carbon monoxide. "OFF" "stop" On/Off Switch OFF Starter Handle Figure 9. Operating the Retractable Starter. "OFF" Figure 12. Engine On/Off Switch. Fuel Shut-Off Valve Choke Lever OFF OFF Figure 13. "Off" Position of Fuel Shut-Off Valve. Figure 10. "Off" Position of Choke Lever. 9 Operating Angle of Operation Carburetor Icing Cooling Air Intake WARNING Hot Parts can cause severe burns. Air Cleaner Cover Figure 14. "Cold Weather Operation" Position of Air Cleaner Cover. Engine components can get extremely hot from operation. To prevent severe burns, do not touch these areas while the engine the engine with heat shields or guards removed. Engine Speed Air Intake Air Cleaner Cover Figure 15. "Normal Operation" Position of Air Cleaner Cover. 10 Maintenance Instructions WARNING Maintenance Schedule Frequency Maintenance Required Check oil level. Fill fuel tank. Daily or Before Starting Engine Check air intake and cooling areas; clean as necessary. ¹ Check air cleaner and precleaner. Yearly or Every 50 Hours Clean or replace precleaner. Clean, set gap or replace spark plug, and set gap. Yearly or Every 100 Hours Yearly or Every 200 Hours Replace air cleaner element. [. . . ] "Normal Operation" Position of Air Cleaner Cover. Air Intake Air Cleaner Cover Figure 26. "Cold Weather Operation" Position of Air Cleaner Cover. 14 Ignition System Wire Gauge Spark Plug Check Spark Plug ® Ground Electrode Figure 27. Servicing Spark Plug. 0. 76 mm (0. 030 in. ) Gap Fuel Tank Cap (Non Evap Shown) Fuel Tank Filter Fuel Tank Filter WARNING Fuel Tank Filler Neck Figure 28. 15 Fuel Valve Fuel Valve Screw Nuts WARNING Cover Screw Figure 29. [. . . ]