User manual KTM 625 LC4 SXC-2003

Lastmanuals offers a socially driven service of sharing, storing and searching manuals related to use of hardware and software : user guide, owner's manual, quick start guide, technical datasheets... DON'T FORGET : ALWAYS READ THE USER GUIDE BEFORE BUYING !!!

If this document matches the user guide, instructions manual or user manual, feature sets, schematics you are looking for, download it now. Lastmanuals provides you a fast and easy access to the user manual KTM 625 LC4 SXC-2003. We hope that this KTM 625 LC4 SXC-2003 user guide will be useful to you.

Lastmanuals help download the user guide KTM 625 LC4 SXC-2003.


Mode d'emploi KTM 625 LC4 SXC-2003
Download
Manual abstract: user guide KTM 625 LC4 SXC-2003

Detailed instructions for use are in the User's Guide.

[. . . ] 625 SXC BEDIENUNGSANLEITUNG OWNER'S MANUAL MANUALE D'USO MANUEL D'UTILISATION MANUAL DE INSTRUCCIONES 2003 Art. Nr. 3. 210. 53 8/2002 IMPORTANT WE STRONGLY SUGGEST THAT YOU READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE GOING ON YOUR FIRST RIDE. IT CONTAINS A GREAT DEAL OF INFORMATION AND ADVICE WHICH WILL HELP YOU USE AND HANDLE YOUR BIKE PROPERLY. IN YOUR OWN INTEREST, PLEASE PAY PARTICULAR ATTENTION TO NOTICES THAT ARE MARKED AS FOLLOWS: IGNORING THESE INSTRUCTIONS, CAN ENDANGER YOUR BODY AND YOUR LIFE. ! [. . . ] ­ HAVING PERFORMED ANY WORK ON THE BRAKING SYSTEM, ONE MUST ALWAYS ACTUATE THE HAND BRAKE LEVER OR FOOT BRAKE LEVER, RESPECTIVELY SO AS TO ENSURE THAT THE BRAKE PADS WILL LIE AGAINST THE BRAKE DISK AND THE PRESSURE POINT IS ESTABLISHED. 29 Check the rear brake fluid level The reservoir for the rear disc brake is located above the main brake cylinder. The level of brake fluid may not fall below the , , MIN" mark when the vehicle has been left standing upright WARNING IF THE BRAKE FLUID LEVEL DROPS BELOW THE MINIMUM EITHER THE BRAKE SYSTEM HAS A LEAK OR THE BRAKE PADS ARE COMPLETELY WORN. IN THIS CASE, CONSULT AN AUTHORIZED KTM DEALER IMMEDIATELY. Refilling the rear brake fluid reservoir * When the brake fluid level has dropped to the MIN mark, you need to refill the brake fluid reservoir. For easier access to the brake fluid reservoir it is recommended to remove the hexagon screw 5. Then move the container outwards as indicated in the illustration. Remove plug 6 with rubber boot 7 and add brake fluid DOT 5. 1 (Shell Advance Brake DOT 5. 1) up to the , , MAX" mark. Overflown or spilled brake liquid must be rinsed off with water. Mount the screw and fix the brake fluid reservoir to the frame, always making sure to prevent kinks in the connecting hose. WARNING ­ NEVER ­ ­ USE DOT5 BRAKE FLUID!IT IS BASED ON SILICONE OIL AND OF A PURPLE COLOR. SEALS AND BRAKE HOSES MUST BE ESPECIALLY ADAPTED TO IT. STORE BRAKE FLUID OUT OF REACH OF CHILDREN. IF YOU GET BRAKE FLUID IN YOUR EYES, RINSE WITH PLENTY OF WATER AND CONSULT A DOCTOR. 5 6 7 !­ DON'T ­ CAUTION ! LET BRAKE FLUID GET IN CONTACT WITH PAINT, IT IS AN EFFECTIVE PAINT REMOVER. USE ONLY CLEAN BRAKE FLUID TAKEN FROM A TIGHTLY SEALED CONTAINER. ENGLISH Mount the right brake pad and fix it with the bolt. Mount the left brake pad and insert the bolt until it stops. When mounting the brake pads, be sure to check for correct fit of the sliding metal-sheet 3 in the caliper support and of the leaf spring 4. Changing the basic position of the brake pedal * 1 A The basic setting of the foot brake pedal can be changed by turning the end stop roller 1. Using the push rod 2, the free play on the foot brake pedal must be set. Measured on the outside, the foot brake pedal must have 3-5 mm of free play, before the push rod can move the piston in the brake cylinder (to be recognised from the resistance on the foot brake pedal). To keep the stop roller from turning while tightening, insert a hexagon wrench in bore A. IF CAUTION ! THIS CLEARANCE IS MISSING, PRESSURE ACCUMULATES IN THE BRAKING SYSTEM AND THE BRAKE PADS BEGIN TO RUB. THE BRAKING SYSTEM OVERHEATS AND CAN FAIL COMPLETELY IN EXTREME CASES. 2 3-5mm min. [. . . ] The information presented results obtainable by skilled drivers under controlled road and vehicle conditions, and the information may not be correct under other conditions. REPORTING SAFETY DEFECTS If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA) in adition to notifying KTM Sportmotorcycle USA, Inc. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remady campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or KTM Sportmotorcycle USA Inc. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1­800­424­9393 (or 366­0123) in Washington D. C. [. . . ]

DISCLAIMER TO DOWNLOAD THE USER GUIDE KTM 625 LC4 SXC-2003

Lastmanuals offers a socially driven service of sharing, storing and searching manuals related to use of hardware and software : user guide, owner's manual, quick start guide, technical datasheets...
In any way can't Lastmanuals be held responsible if the document you are looking for is not available, incomplete, in a different language than yours, or if the model or language do not match the description. Lastmanuals, for instance, does not offer a translation service.

Click on "Download the user manual" at the end of this Contract if you accept its terms, the downloading of the manual KTM 625 LC4 SXC-2003 will begin.

Search for a user manual

 

Copyright © 2015 - LastManuals - All Rights Reserved.
Designated trademarks and brands are the property of their respective owners.

flag