User manual KTM 690 SUPERMOTO

[. . . ] OWNER'S MANUAL 2008 690 SUPERMOTO 690 SUPERMOTO R ART. 3211244en DEAR KTM CUSTOMER Congratulations on your decision to purchase a KTM motorcycle. You are now the owner of a state-of-the-art sports motorcycle that will give you enormous pleasure if you service and maintain it accordingly. We wish you great pleasure riding the vehicle! 1 Enter the serial numbers of your vehicle below. [. . . ] Have the front and rear brake fluid replaced according to the service plan in an authorized KTM workshop. MAINTENANCE WORK ON CHASSIS AND ENGINE (690 SUPERMOTO) The brake fluid level must not fall below the center of the level viewer brake fluid reservoir is vertical. » If the brake fluid level is lower than the center of the level viewer: Top up the brake fluid of the front brake. 72 when the x( P. 72) 100136-10 (690 SUPERMOTO R) The brake fluid level must not fall below the MIN marking reservoir is vertical. » If the brake fluid is below the MIN marking: Top up the brake fluid of the front brake. when the brake fluid x( P. 72) 100134-10 Topping up the front brake fluid Warning x Danger of accidents Brake system failure. MINIf the brake fluid level falls below the MIN mark, this indicates a leakage in the brake system or worn-out brake linings. Have the brake system checked in an authorized KTM workshop, and do not ride any further. MAINTENANCE WORK ON CHASSIS AND ENGINE Warning Skin irritations Brake fluid can cause skin irritation on contact. Avoid contact with skin and eyes, and keep out of the reach of children. If brake fluid gets into your eyes, rinse thoroughly with water and contact a doctor immediately. 73 Warning Danger of accidents Reduced braking due to old brake fluid. Have the front and rear brake fluid replaced according to the service plan in an authorized KTM workshop. Warning Environmental hazard Problem materials cause environmental damage. Dispose of oil, grease, filters, fuel, cleaning substances, brake fluid, batteries, etc. according to regulations. Info KTM recommends DOT 5. 1 brake fluid from Motorex®. This has a higher wet boiling point than DOT 4 brake fluid and provides greater safety for high demands. This is based on silicone oil and is colored purple. Oil seals and brake lines are not designed for DOT 5 brake fluid. Avoid contact between brake fluid and painted parts. Use only clean brake fluid from a sealed container!Move the brake fluid reservoir mounted on the handlebar to a horizontal position. MAINTENANCE WORK ON CHASSIS AND ENGINE (690 SUPERMOTO) Remove screws Remove the cover Specification Measurement of Brake fluid DOT 5. 1 ( 100180-10 74 . 152) . Top up brake fluid to level Check parts for damage and wear. Mount and tighten screws. Info Clean up overflowed or spilt brake fluid immediately with water. Mount and tighten screws. Info 100181-10 Clean up overflowed or spilt brake fluid immediately with water. MAINTENANCE WORK ON CHASSIS AND ENGINE Brake linings The brake linings fitted by KTM were tested over long periods and ensure optimal braking properties. The type names of brake pads are entered in the homologation documents. 75 Info Brake linings available from accessory suppliers are often not tested and approved for use on KTM vehicles. [. . . ] Supplier Motorex Motorex® Joker 440 Universal STANDARDS JASO T903 MA 157 Different technical development directions required a new specification for 4-stroke motorcycles the JASO T903 MA Standard. Earlier, engine oils from the automobile industry were used for 4-stroke motorcycles because there was no separate motorcycle specification. Whereas long service intervals are demanded for automobile engines, high performance at high engine speeds are in the foreground for motorcycle engines. With most motorcycles, the gearbox and the clutch are lubricated with the oil as the engine. [. . . ]