User manual LIFT-MASTER GTW

[. . . ] A DUCHOSSOIS ENTERPRISE 845 Larch Avenue Elmhurst, Illinois 60126 OWNER'S MANUAL SERIES 3000 MODEL GTW NEMA 4 GEARHEAD TROLLEY OPERATOR ADDENDUM REFER TO MODEL GT INSTALLATION INSTRUCTIONS OUR LARGE SERVICE ORGANIZATION SPANS AMERICA INSTALLATION AND SERVICE INFORMATION ARE AVAILABLE 6 DAYS A WEEK CALL OUR TOLL FREE NUMBER 1-800-528-6563 HOURS 7:00 TO 3:30 P. M. (MOUNTAIN STANDARD TIME) MONDAY THROUGH SATURDAY Serial # ____________________ (located on electrical box cover) Date of Installation ____________ Wiring Type _________________ ® ® COMMERCIAL DOOR OPERATOR LISTED NOT FOR RESIDENTIAL USE ADJUST LIMITS WARNING TO AVOID SERIOUS PERSONAL INJURY OR DEATH FROM ELECTROCUTION, DISCONNECT ELECTRIC POWER BEFORE MANUALLY MOVING LIMIT NUTS. MAKE SURE THE LIMIT NUTS ARE POSITIONED BETWEEN THE LIMIT SWITCH ACTUATORS BEFORE PROCEEDING WITH ADJUSTMENTS. To increase door travel, spin nut away from actuator. [. . . ] Yellow 1 2 4 Remove Jumper to Install Timer Defeat Switch. P2 14 13 12 11 10 9 8 7 6 5 4 3 2 1 P1 TI TL S SW5 SW4 T6 T5 SW3 T4 SW2 T3 SW1 T2 T1 L1 L2 L3 Open IR 14D0379 LOAD Interlock (When Used) Black Orange Orange Black T12 T11 T10 1 2 3 T9 T8 T7 OVERLOAD PROTECTOR GND Open/Close RADIO CONTROL Close Sensing Device Stop Open/Timer Close Hot 115V 1Ø Hot 230V 1Ø Neutral 115V 1Ø Hot 230V 1Ø 3 SINGLE PHASE SCHEMATIC DIAGRAM - GTW NEMA 4 (For P. C. Board #14D0379) Neutral 115v 1Ø Hot 115v 1Ø L1 White L2 L3 Black Single Phase Overload Protector Orange Red 115 Vac Only P1-4 7 Red L2 L3 C O Red OT2 C L1 L2 Red Red Orange Red Place Jumper Between 3 & 4 If a Stop Button Is Not Used. 4 3 P2-13 1 P3-1 (To Radio) 1 2 3 Radio Control O C Rollback Option Sense to Reverse 6 8 P2-14 Brown 27 P1-10 * NOTE: Remove Jumper If External Interlock is Used. External Interlock* 5 P2-11 Red (When Used) Jumper Orange P1-8 4 SW1 SW1 O Orange P3-2 (To Radio) 2, 200µ IR1 6 A1 P2-6 Orange Red OT3 O L1 Blue Yellow Red Red OT1 O L3 C TD1 TD2 Orange Black Rect. Bridge O C GND The Chamberlain Group, Inc. Schematic Diagram Standard Duty GTW Single Phase - NEMA 4 3/19/92 - 9/13/92 IR 8 P1-1 MOTOR Internal Interlock T1 24 Vac Red STOP OLS O Red P2-10 OPEN A2 Time Capsule >1 HP 12 P3-4 (To Radio) + TD1 27 TD2 + SW1 SLS P1-9 3 7 220µ S 8 SW2 S-1 4 6 P2-12 7 Open/Close ADLS TL-2 Brown SW5 TS SW4 TS Grey 3 5 TI-1 C 5 Grey 10 Open/Timer to Close 7 8 (Optional) TI P2-10 SW3 P1-14 P1-13 Blue P2-1 4 6 SW2 S W 3 2 Blue TIMER TO CLOSE ONLY TL-1 8 7 (Optional) TL C 3 IR2 5 Blue A1 P1-7 A2 CLOSE Close Timer 1 11 9 TI-2 Timer Defeat Switch 5 C Blue 1 P1-11 S-2 5 CLS P2-7 P1-12 4 GTW NEMA 4 WITH DYNAMIC BRAKE - 3 PHASE WIRING DIAGRAM (For P. C. Board #14D0379) Red Gray Yellow SENSING NC LIMIT SWITCH NO C CLOSE NC LIMIT SWITCH NO C Red Red Yellow Gray Blue Orange Orange Brown Brown Yellow Blue 3/4 to 2HP 3 Phase Overload Orange Red White T3 T2 T1 A2 14 T3 T2 T1 NO NO NO NO Brown Brown Blue NC AUXILARY DEVICE LIMIT NO SWITCH C Orange NC NO Red Red OPEN LIMIT SWITCH C P1 12 4 14D383A 1 P2 789 14 Red Gray Yellow White Blue Blue Orange LOAD LINE Orange BRAKE LINE XMFR LOAD Orange Blue Red Red A2 96 95 14 T3 T2 T1 NO NO NO NO 1. 5 Sec. TIMER Yellow Brown Blue Gray Orange *1/3 & 1/2 HP Three Phase Gray 81 71 53 81 Yellow 71 53 Gray OPEN NO NO NO NO CLOSE NO NO NO NO Red Red 82 72 54 82 72 54 Blue Orange Yellow Red Black MOTOR 13 L3 L2 L1 Orange A2 Org. Orange Orange Blue Blue Blue Red Yellow Blue Org. Blue Brown Brown A1 13 L3 L2 L1 A2 A1 Yellow Yellow Red Black Red Black Blue Gray Yellow Red Red Red Orange Blue Brown Red Red Red Blue LOAD Red Red LINE Red LINE LOAD 14D0379 JU2 JU1 SW1 T3 T2 T1 Interl'k (When Used) STANDARD TRANSFORMER 14 13 12 11 10 9 8 7 6 5 4 3 2 1 P3 Brown Gry. /Wht. Yellow 1 2 4 T12 T11 T10 T9 T8 P2 Remove Jumper to Install Timer Defeat Switch. SW5 T7 TI 14 13 12 11 10 9 8 7 6 5 4 3 2 1 P1 TL S SW2 T4* Red Red SW4 T6 SW3 T5* 1 2 3 Open/Close Open L1 L2 L3 Close RADIO CONTROL Sensing Device Stop Open/Timer Close GND · For 3/4 HP Install Interlock Between T4 and T5 L1 L2 L3 External Interlock If Required On 1/3 & 1/2 HP 3Ø 5 THREE PHASE SCHEMATIC DIAGRAM - GTW NEMA 4 (For P. C. Board #14D0379) Hot 3Ø L1 White T1 Three Phase Overload Relay (3/4 HP to 2 HP Only) L1 Red Red Red L2 L3 C Red P1-4 P1-1 Red OT1 O Red OT2 C L1 L2 Red Red Orange Red Red OT3 O L1 Blue Yellow O L3 C TD1 TD2 Orange L2 Red L3 Orange Black Rect. [. . . ] 575V NEMA Spacer Limit Switch Seal, Shaft Washer-Sealing 1/2" Connectors-Straight1/2" Conduit, Liquid Tight Connector- 90º 1/2" Motor S. D. NEMA Box Mounting Stand-Off (575V) PCB Mounting Bracket PCB Assy. Dynamic Brake 4 8 9 10 12B494 12B495 31A374 180B159-3 13 11 180B159-6 180B159-4 ©1992, The Chamberlain Group All Rights Reserved Printed in Mexico 16 17 18 9 5 13 180B159-1 180B159-4 180B159-1 12 1D4113 1D4438 184A115 168A2 216A176 23A80 172A36 23A79 123D128 19 123D129 123D130 123D131 123D132 3 15 6 22 8 14 15 16 24 12 14 2 20 7 1 21 23 19 17 18 123D133 123D154 20 21 22 23 24 12C510 12C510-1 184A136 12B529 1C4312 [. . . ]