User manual LOTUS ELISE BODY FITTINGS BP 2001

[. . . ] Vacuum Pipes, Valves, Flaps, Actuators, Vacuum Pump Intake Plenum, Ducting Outlets & Vents Labels & Literature 19. 01A 19. 03A Labels Owner's Handbooks & Service Notes Manuals Suspension 31. 01A 31. 03A Front Suspension & Hubs Rear Suspension & Hubs Steering 32. 03A 32. 05A Power Steering Rack, Lower Column Upper Steering Column & Wheel, Lock & Ign. Switch Brakes 33. 01A 33. 01B 33. 01C 33. 03A 33. 03B 33. 05A S4 Prior VIN*: Brake Calipers & Discs S4 From VIN*: Brake Calipers & Discs Sport 300: Brake Calipers & Discs Booster/Master Cylinder, Pump, Accumulator Hydraulic System, Brake Pipes & Hoses Parking Brake Mechanism Engine 40. 01A 40. 03A 40. 05A 40. 07A 40. 09A 40. 11A 40. 13A 40. 15A 40. 17A 40. 19A 40. 21A 40. 23A 40. 25A 40. 28A 40. 28B Block, Main Bearing Housing, Engine Mountings Oil Sump Cylinder Head & Gasket, Valves, Guides & Springs Cam Housings, Camshafts, Tappets Pistons & Liners, Connecting Rods Crankshaft, Flywheel Water Pump Auxiliary Housing, Oil Pump, Turbo Oil Pipes D. I. Leads, Spark Plugs Alternator, Starter Motor Exhaust Manifold, Turbocharger A. C. Compressor, Mounting Bracket, Jocky Wheel Power Steering Pump, Pulley, Mounting Bracket Engine Upper Gasket Set Engine Lower Gasket Set Belts & Pulleys 41. 01A 41. 03A Camshaft Belt, Toothed Pulleys, Tensioner Auxiliary Drive Belts & Pulleys Induction System 42. 01A 42. 07A Airbox, Chargecooler, Intake Plenum Inlet Manifold, Fuel Rail, IAC Valve Fuel System 44. 01A 44. 03A 44. 05A Fuel Tanks, Filler Necks, Gauge Sender Unit Fuel Pump, Filter, Fuel Pipes Evaporative Loss System Exhaust System 45. 01A 45. 05A Exhaust System & Mountings, Ex. [. . . ] Rear Wheel Speed Sensors The rear wheel speed sensors are mounted in the cast alloy rear suspension uprights, with the pole wheels pressed onto the outboard driveshaft C. V. The gap between sensor tip and pole wheel should be 0. 6 - 1. 4 mm (0. 024 - 0. 055 in). There is no provision for adjustment, and if the gap is found to be outside specification, check for an incorrectly seated sensor, displaced pole wheel or faulty wheel bearings. Note that on fuel injected cars, the right hand rear hub carrier also houses a vehicle speed sensor for the engine management system. The electrical connector on this sensor, has a vertical axis. Page 66 RH rear wheel speed sensor --L Rear hub //f / carrier Rear hub I:I Wheel speed sensor ring' (pole wheel) JF. 20 - PROPORTIONING VALVE , I -il 1 C. V. joint The proportioning valve is fitted into the rear brake circuit at the right hand front of the engine bay, and under normal circumstances has no effect on the standard or anti-lock braking system. The purpose of the valve is to prevent over adjustment of the rear caliper parking brake mechanism if abnormally high To Lki rear To RF1 rear brake Pressure proportioning Powermaster \ \ \ Y balance pipe Page 67 pressures are produced in the rear brake line, such as may occur if the pedal is vigourously pressed with the vehicle stationary (when the ABS does not operate to control pressures). The valve also serves to divide the supply into separate right and left h&-id circuits. To replace the valve, use a 17 mm wrench to prevent the adaptors from turning whilst the brake pipe sleeve nuts are released. Use a shop towel to absorb any escaping fluid, and cap the pipe ends and valve ports immediately after disconnection. Release the valve fixing screw and remove the valve. JF. 21 - ABS CONTROLLER, RELAYS & FUSES The ABS controller, or electronic control unit (ECM), is mounted on the passenger side front bulkhead in the front luggage compartment. The mounting bracket uses a clamping channel to secure the ECM to the bracket, and also carries a row of relays and fuses, and on pre `revised harness' cars, the wheel speed sensor harness connector socket. ABS Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Front Enable Relay . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Rear Enable Relay . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Front and rear Solenoids . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Wheel Speed Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Brake Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Pump Motor Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ABS Tell Tail . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Lamp Driver Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Self Diagnostic Capabilities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ] Mounting Bracket, gearbox, RH Mounting Bracket, gearbox, LH. Washer, flat, Ml 0 x 20, bracket t o gearbox. Ola 01 b 01 c 02 02a 02b 02c 02d 03 03a 03b 04 05 06 07 08 1 1 1 1 1 1 1 1 1 GT3, prior to VIN: W2272 GT3, VIN: W2272 on V8, B918E0150K V8 . . V8, prior to `98 MY V8, V8-GT, GT3 V8, prior to `98 MY GT3 V8, V8-GT, , 98 MY on, GT3, VIN W2272 on `98 MY on R/B 1 2 2 1 1 6 Function Code: 47. 03, Page: 1 Function Code 47. 03 Transmission Assembly Dep 09 IO 11 Part Description Remarks Option Part Number A082W7057F A075W2061Z A075W2056F A075W2059Z A075W1049Z Qty 1 1 1 Screw, Ml0 x 45, button hd. , bracket to gearbox. LH: 1 off, RH: 2 off Marked: 17-l 917R Marked: 17-l 917L 12 13 14 15 16 17 18 19 20 2 1 A075W4006Z A91 8E0265F A91 8E0266F A075W1038Z . A075W4020Z A075W301 OZ A082F4113F A082W4112F A075W4005F A075W3004Z A082F6564F 1/2 1 1 4 4 4 Mounting Rubber, gearbox. [. . . ]