User manual NOVAK FIFTY-FIVE REV1 11-2007

[. . . ] ·NOSCHOTTKYDIODESWITHREVERSIBLEESCs NEVER use Schottky diodes on the motor with reversible ESCs--ESC damage will occur. ·SETGEARMESHPROPERLY Too tight of a gear mesh can result in motor pinion shaft breakage--be sure to adjust mesh properly. PRECAUTIONS ·WATER&ELECTRONICSDON'TMIX Never allow water, moisture, or other foreign materials to get inside motor, or on PCBs. ·CHECKMOTORSCREWS Remember to check all motor screws for loosening after a few runs of the motor. ·INSULATEWIRES Always insulate exposed wiring with heat shrink tubing to prevent short circuits. [. . . ] Apply heat with soldering iron to the power wire and solder tab--begin adding solder to tip of iron and to wire--Add just enough solder to form a clean & continuous joint from the solder tab up onto the wire. PRODUCT WARRANTY Novak products are guaranteed to be free from defects in materials or workmanship for a period of 120 days from the original date of purchase (verified by dated, itemized sales receipt). Warranty does not cover incorrect installation, components worn by use, cross-connection of battery/motor power wires, overheating solder tabs, damage resulting from overload, wear or damage from improper gear mesh, damage from disassembling motor or incorrect re-assembly of motor, tampering with motor, allowing water, moisture, or any other foreign material to enter motor, allowing exposed wiring or solder tabs to short-circuit, or any damage caused by a crash, flooding, or act of God. In no case shall our liability exceed the product's original cost. We reserve the right to modify warranty provisions without notice. has no control over the connection & use of motor or other related electronics, no liability may be assumed nor will be accepted for damage resulting from the use of this product. Every motor is tested before leaving our facility and is, therefore, considered operational. By the act of connecting motor to speed control or operating motor, the user accepts all resulting liability. PRODUCT WARRANTY Novak products are guaranteed to be free from defects in materials or workmanship for a period of 120 days from the original date of purchase (verified by dated, itemized sales receipt). Warranty does not cover incorrect installation, components worn by use, cross-connection of battery/motor power wires, overheating solder tabs, damage resulting from overload, wear or damage from improper gear mesh, damage from disassembling motor or incorrect re-assembly of motor, tampering with motor, allowing water, moisture, or any other foreign material to enter motor, allowing exposed wiring or solder tabs to short-circuit, or any damage caused by a crash, flooding, or act of God. In no case shall our liability exceed the product's original cost. We reserve the right to modify warranty provisions without notice. has no control over the connection & use of motor or other related electronics, no liability may be assumed nor will be accepted for damage resulting from the use of this product. Every motor is tested before leaving our facility and is, therefore, considered operational. By the act of connecting motor to speed control or operating motor, the user accepts all resulting liability. ACCESSORIES 5460 3AmpUniversalBEC--6VDC/3A output Battery Eliminator Circuit for 6. 3-8. 4VDC input. 5463 3AHigh-VoltageUniversalBEC--6VDC/3A output B. E. C. 5465 5AmpUniversalBEC--6VDC/5A output Battery Eliminator Circuit for 6. 3-8. 4VDC input. 5470 Smart-Stop2-cellLi-PoCut-OffModule--Safe 2S Li-Po operation with 6. 25V cut-off. 5471 Smart-Stop4-cellLi-PoCut-OffModule--Safe 4S Li-Po operation with 12. 5V cut-off. 5472 Smart-Stop3-cellLi-PoCut-OffModule--Safe 3S Li-Po operation with 9. 375V cut-off. 5485 4-CellTransponderVoltageBooster--Boosts voltage to transponder--No missed laps. 5500 14GASuper-FlexWire--Black&Red--3 ft each color, silicone. 5505 14GASuper-FlexWire--Blue&Red--3 ft each color, silicone. 5510 16GASuper-FlexWire--Black&Red--3 ft each color, silicone. [. . . ] 5626 GlitchBusterCapacitor--Stores battery power for receiver to eliminate radio cut-out. 5636 RacingSchottkyMotorModule--36A Schottky module for forward-only ESCs. 5647 BlackCoolingFan--25x25x10mm--All purpose cooling fan with 2-pin JST connector. 5648 ClearCoolingFan--30x30x6mm--GTB replacement fan with 2-pin JST connector. [. . . ]