User manual OPTICON OPN 2001

[. . . ] Data Collector--Single Tray OPN 2001 The OPN 2001 is a compact and cordless laser scanner that outputs all stored data through a USB interface. Specifications Manual Opticon OPN 2001 Specifications Manual All information subject to change without notice. Document History Model Number: Edition: Date: OPN 2001 USB 1A 2006-12-5 Specification Number: Original Spec Number: CS06164 CS06143 Copyright 2008 Opticon. All rights reserved. This manual may not, in whole or in part, be copied, photocopied, reproduced, translated or converted to any electronic or machine readable form without prior written consent of Opticon. Limited Warranty and Disclaimers PLEASE READ THIS MANUAL CAREFULLY BEFORE INSTALLING OR USING THE PRODUCT. Serial Number A serial number appears on all Opticon products. This official registration number is directly related to the device purchased. [. . . ] 16 Figure 8: Mini USB B connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 Figure 9: Serial number label . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 Figure 10: Individual packaging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 Figure 11: Collective packaging. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 Figure 12: Shock (drop) test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Figure 13: Mechanical drawing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 5 Opticon OPN 2001 Specifications Manual 1. Recommended Operating Conditions Item Power supply voltage Input voltage Symbol VDD Vin Conditions Battery USB Min 3. 1 4. 5 0 Typ 5. 0 Max 4. 2 5. 5 VDD Unit 6. 3. Electrical Characteristics Parameter During Scanning Operating current * Communicating Standby Charging When OFF Voltage between terminals Battery specifications Rated capacity Charging current Charging time Scans when fully charged ** Start up time Td ICHG2 Tchg Symbol IOP Icom IPRE ICHG1 Ioff VBAT Min 93 41 24 106 17 2. 75 140 59 1000 - Typ 96 43 25 113 18 3. 7 150 66 50 Max 150 45 26 120 19 4. 2 73 2. 5 - Unit mA mA mA mA A V mAh mA hour times ms Conditions · · · Connect 1 resistance to a 3. 7 volt power supply line in series and measure the current by the voltage between both ends of resistance. Power supply voltage is measured at the terminal of the secondary battery. The operating current specifications for power charging or communicating are described based on the power current from the USB interface. 8 Opticon OPN 2001 Specifications Manual · The number of scans when fully charged is determined based on a scanning operation where the laser beam is on for 4 seconds and the lighting LED is on for 1 second per scan. 6. 4. Main Battery The main battery is a lithium-ion rechargeable battery. Nominal capacity: 150 mAh Nominal voltage: 3. 7 V DC 6. 5. Battery Operating Time and Charging Time Parameter Main battery pack operating time Current consumption Power management Charging time Charging method Specification 1000 scans 100 mAh operation, idle Extreme low power 2 ½ hours Recharging lithium-ion pack in scanner via USB port Notes Conditions: Every scan, 2 seconds laser beam on and 1 second good read LED on Note: Battery life may be shorter than specified above when the quality of the battery pack is degraded. 7. Laser Scan Specifications Parameter Light-emitting element Emission wavelength Light output Scanning method Scanning speed Scan angle Specification Red laser diode 650 ±10 (25° C) 1. 0 or less Bi-directional scanning 100 ±20 Scan angle: 54 ±5 Read angle: 44 (Min) Unit -- nm mW -- scans/s ° ° Notes: Refer to chapter 8, "Technical Specifications, " to read about scanning performance. 9 Opticon OPN 2001 Specifications Manual 7. 2. Laser Scanning Tilt Laser scanning tilt is the vertical difference between both ends of a laser scan line. Measure it in the middle of the laser scan line. · Up to 0. 92 degrees angle in a vertical direction from the scan origin (mirror motor). · Up to 2. 46 mm at 150 mm from the scan origin. 7. 2. 2. Scanning Curvature The maximum difference between the laser scan line and the line between both ends of the laser scan line. Measure it in the middle of the laser scan line. · Up to 1. 17 degrees angle in a vertical direction from the scan origin (mirror motor). [. . . ] These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses, and can radiate radio frequency energy and if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one of the following measures: · · · · Reorient or relocate the receiving antenna. [. . . ]