User manual SHARP AL-2040FK

[. . . ] MODEL AL-2020 AL-2040 DIGITAL MULTIFUNCTIONAL SYSTEM OPERATION MANUAL Page INTRODUCTION SETTING UP THE UNIT LOADING PAPER INSTALLING THE SOFTWARE MAKING COPIES SPECIAL FUNCTIONS MAINTENANCE TROUBLESHOOTING THE UNIT APPENDIX 4 7 14 19 46 52 57 62 70 AL-2020 AL-2040 Shielded interface cables must be used with this equipment to maintain compliance with EMC regulations. Do not make copies of anything which is prohibited from copying by law. The following items are normally prohibited from copying by national law. Other items may be prohibited by local law. Money Stamps Bonds Stocks Bank drafts Checks Passports Driver's licenses In some areas, the "POWER" switch positions are marked "I" and "O" on the copier instead of "ON" and "OFF". [. . . ] Replace the old TD cartridge by following the procedure below. · After the unit stops, it may be possible to make a few more copies by taking the TD cartridge out of the unit, shaking it horizontally, then reinstalling it. If copying is not possible after this operation, replace the TD cartridge. · During long copy run of a dark original, the TD cartridge replacement required ( ) indicator may light up, the start ( ) indicator blink, and the unit stops, even though toner is left. The unit will feed toner up to 2 minutes and then the start ( ) indicator will light up. Press the start ( ) key to restart copying. 1 Open the multi-bypass tray, side cover, and front cover, in that order. To open the multi-bypass tray, see "The multi-bypass tray" (p. 17). To open the side cover and front cover, see "INSTALLING THE TD CARTRIDGE" (p. 10). 2 Gently pull the TD cartridge out while pressing the lock release button. Lock release button 7 Dispose of the old TD cartridge in accordance with local regulations. 3 Install a new TD cartridge. To install the new cartridge, see "INSTALLING THE TD CARTRIDGE" (p. 10). 57 4 Close the front cover and then the side cover by pressing the round projections near the side cover open button. The indicator ( ) will go out and the start ( ) indicator will light up. When closing the covers, be sure to close the front cover securely and then close the side cover. If the covers are closed in the wrong order, the covers may be damaged. DRUM CARTRIDGE REPLACEMENT The useful life of the drum cartridge is approximately 18, 000 copies*. When the internal counter reaches approximately 17, 000 copies, the drum replacement required ( ) indicator will light up indicating that replacement of the drum cartridge will be needed soon. For more information on purchasing the drum cartridge, see "ABOUT SUPPLIES AND OPTIONS" (p. 72). When the indicator begins to blink, the unit will stop operating until the cartridge is replaced. Replace the drum cartridge at this time. *Based on copying onto A4 size paper at 5% toned area. Do not remove the protective cover on the drum portion (black paper) of a new drum cartridge before use. The cover protects the drum against external light. 1 2 Remove the TD cartridge (see step 1 and 2 in "TD CARTRIDGE REPLACEMENT" (p. 57)). Hold the drum cartridge handle and gently pull the cartridge out. Dispose of the old drum cartridge in accordance with local regulations. Drum cartridge handle Dispose of the old drum cartridge in accordance with local regulations. 58 3 Remove the new drum cartridge from the protective bag and remove the protective cover from the cartridge. Then gently install the new drum cartridge. Do not touch the surface of the drum (green portion) of the cartridge. Doing so may cause smudges on the copies. 4 5 Gently install the TD cartridge. To install the TD cartridge, see step 5 in "INSTALLING THE TD CARTRIDGE" (p. 10). [. . . ] In other Countries outside the EU If you wish to discard this product, please contact your local authorities and ask for the correct method of disposal. For Switzerland: Used electrical or electronic equipment can be returned free of charge to the dealer, even if you don't purchase a new product. Further collection facilities are listed on the homepage of www. swico. ch or www. sens. ch. Information on Disposal for Business Users. 1. [. . . ]