User manual SHOPRIDER 889B-4

[. . . ] Heavy Duty Scooters SPRINTER XL4 (889B-4) SPRINTER XL3 DELUXE (889-3XLS) SPRINTER XL4 DELUXE (889-4XLS) SPRINTER JUMBO XL (889X) User Manual Contents INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 FEATURE GUIDE (FIG. 1-4) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 SAFETY ADVICE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 EMI Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 ADJUSTMENTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Tiller Angle Adjustment (Fig. 5) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Seat Slide & Swivel Adjustment (Fig. 6). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Seat Removal (Fig. [. . . ] The seat height can be adjusted to 5 different settings by inserting the steel locking pin in the required hole. Retighten the hand knob and replace the seat. 8) On the underside of the seat there are two hand knobs, one either side. Loosening the hand knob allows the arm rest to be adjusted to the required width, or removed for transportation. DO NOT USE SCOOTER WITHOUT THE ARM RESTS BEING FITTED & SECURED. Tiller Angle Adjustment Lever Figure 5 Swivel Seat Adjustment Lever Seat Slide Lever Figure 6 Seat Adaptor Seat Tightening Hand Knob Seat Locking Pin Figure 7 Armrest Adjustment Hand Knob Figure 8 8 12/29/2004 Armrest Angle Adjustment (Fig. 9) Flip up the armrests to allow access to the adjustment screw and lock nut, unscrew the lock nut and screw the bolt in or out to increase or decrease the angle. The armrests are set parallel to the floor at the factory. Locking Nut and Bolt Adjustment Screw Figure 9 Reclining Seat (Fig. 10) Sprinter XL4 Deluxe & Sprinter XL3 Deluxe The Sprinter XL4 Deluxe and Sprinter XL3 Deluxe come standard with a reclining seat. The reclining seat lever is located on the left side below the armrest. This feature also allows the seat to be folded down. Figure 10 12/29/2004 9 SCOOTER TILLER CONTROLS (FIG. 11A, 11B & 11C) Speed Controls The speed control dial allows you to set a speed Speed Control between 1 (minimum) and 10 (maximum). The Sprinter XL3 Deluxe, XL4 Deluxe, and Jumbo XL are also equipped with a speed high/low switch. Battery Level Indicator Key Switch Battery Level Indicator/Gauge The number of LED bars lit/where the needle rests, shows the amount of charge left in your batteries. The amount of charge will only show at its true level when the scooter is in drive. CAUTION ­ Do not allow the LED bars/gauge needle go out/down completely as complete discharge of the batteries could cause irreversible damage. Lights A blue button located at tiller controls operates lights. Horn A yellow button located at the tiller controls operates the horn. Thumb/Finger Accelerator Lever Controls The right thumb/finger accelerator lever controls the forward motion and the left thumb/finger accelerator lever controls the reverse motion. The amount of pressure applied to each lever will determine the speed the scooter travels at. Release the lever and the scooter will slowly come to a stop. On/Off Key Switch Insert the key in the right side of the tiller. [. . . ] Fitted for extra protection is a circuit breaker, should there be a situation that your scooter stops for no apparent reason please check that the circuit breaker has not popped out or tripped. The circuit breaker can be found under the rear chassis cover accessible through a port hole under the seat. Check List If your scooter fails to operate, please check the following: · Unit is switched on. · All plugs and connectors are firmly fixed. [. . . ]