User manual SONY HDR-PJ660VE

[. . . ] Side Control Module Removal . . . . . . . . . . . . . . . . . . . . Service Connector for M Board . . . . . . . . . . . . . . . . . . . . Picture Tube Removal . . . . . . . . . . . . . . . . . . . . 13 13 13 14 14 14 14 15 15 15 16 17 . . . . . . . . . . . . . . . . . . . . [. . . ] Service Connector for M Board From M Board To A Board Extender Board Assembly A-1642-293-A To remove the M Board gently release the two clips with a screwdriver and remove the board from its socket vertically. If the M Board needs to be removed for testing when the chassis is placed in its service position, it would be necessary to use an extender board and extension cable as indicated above. The Extender board and extension cable are available as a service part by ordering the part number as indicated. 2-10. Wire Dressing 20mm 20mm Ensure that wires do not touch heatsinks and high temperature hotspots. All wires must be kept at a minimum distance of 20mm away from the EHT lead - 15 - 2-11. Picture Tube Removal 10 9 8 WARNING: BEFORE REMOVING THE ANODE CAP High voltage remains in the CRT even after the power is disconnected. To avoid electric shock, discharge CRT before attempting to remove the anode cap. Short between anode and CRT coated earth ground strap. 7 1 3 2 6 Coated Earth Ground Strap 5 4 1. 2. Discharge the anode of the CRT and remove the anode cap. Unplug all interconnecting leads from the Deflection yoke, neck assy, degaussing coils and CRT grounding strap. Loosen the Neck assembly fixing screw and remove. Loosen the Deflection yoke fixing screw and remove. Move the deflection yoke backwards and adjust with the purity magnet so that the red is at the centre and it aligns symmetrically [See Fig. 3-5]. Move the deflection yoke forward to the point where the entire screen just becomes red [Mark its position]. Move the deflection yoke further forward until the screen just changes colour at the edges. Position the deflection yoke between the two marks indicated above. Input a crosshatch pattern from the pattern generator and rotate the deflection yoke so that the horizontal lines are parallel with the top and bottom of the screen. When the position of the deflection yoke has been determined, fasten it with its fixing screw. Switch the pattern generator to green then blue and confirm the purity. If the beam does not land correctly in all the corners of the screen, use disk magnets to correct it. [Confirm the corner landing forgreen and blue] (1) Adjustment of Correction Magnet for Y-Splitting Axis. Input a crosshatch signal from the pattern generator. Set the Picture control to minimum and confirm that the Brightness control is set to normal. [. . . ] C5122 C5123 C5124 C5125 C5300 C5301 C5302 C5303 C5304 C5305 C5306 C5307 C5309 C5310 C5311 C5312 C5313 C5314 C5316 C5318 C5319 C5320 C5321 C5322 C5323 C5400 C5401 C5403 C5404 C5405 C5406 C5407 C5409 C5410 C5411 C5412 C5413 C5414 C5801 C5850 C5851 C5853 C5854 C5858 C5859 C5860 C5868 C5872 C5873 C5888 PART. NO 1-164-156-11 1-126-964-11 1-164-156-11 1-126-964-11 1-126-933-11 1-126-947-11 1-164-222-91 1-136-153-00 1-164-182-11 1-165-176-11 1-164-156-11 1-164-156-11 1-162-927-11 1-136-165-00 1-164-156-11 1-165-176-11 1-107-714-11 1-162-970-11 1-164-230-11 1-164-156-11 1-136-347-11 1-129-716-00 1-136-347-11 1-164-156-11 1-136-159-00 1-126-964-11 1-107-714-11 1-128-527-11 1-102-228-00 1-163-021-91 1-129-702-00 1-128-527-11 1-126-968-11 1-163-021-91 1-137-401-11 1-106-220-00 1-130-785-11 1-126-964-11 1-126-963-11 1-126-963-11 1-107-826-11 1-162-970-11 1-107-826-11 1-107-826-11 1-126-960-11 1-165-176-11 1-164-004-11 1-164-346-11 1-163-251-11 1-164-156-11 DESCRIPTION CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT 0. 1UF 10UF 0. 1UF 10UF 100UF REMARK 25V 20. 00% 50V 25V 20. 00% 50V 20. 00% 16V 20. 00% 25V 25V 5. 00% 50V 10. 00% 50V 10. 00% 16V 25V 25V 5. 00% 50V 5. 00% 50V 25V 10. 00% 20. 00% 10. 00% 5. 00% 16V 50V 25V 50V 25V REF. NO. C5889 C5890 C5891 C5892 C5893 C5894 C5895 C5896 C5897 C5898 C5899 C6200 C6201 C6202 C6203 C6204 C6205 C6206 C6207 C6208 C6209 C6210 C6211 C6212 C6213 C6214 C7002 C7004 C7008 C7016 C7018 C7019 C7020 C7021 C7022 C7023 C7030 C7031 C7032 C7038 C7039 C7050 C7051 C7052 C7053 C7054 C7055 C7056 C7057 C7058 - 61 - PART. NO 1-126-964-11 1-164-227-11 1-137-581-11 1-107-826-11 1-126-947-11 1-126-947-11 1-164-156-11 1-165-176-11 1-162-970-11 1-162-964-11 1-107-823-11 1-126-933-11 1-126-935-11 1-126-933-11 1-126-935-11 1-126-933-11 1-126-935-11 1-126-933-11 1-126-933-11 1-126-933-11 1-126-933-11 1-126-935-11 1-126-947-11 1-126-933-11 1-126-933-11 1-126-933-11 1-126-947-11 1-164-222-91 1-162-919-11 1-107-823-11 1-164-004-11 1-164-004-11 1-164-004-11 1-164-004-11 1-164-004-11 1-164-004-11 1-164-004-11 1-164-004-11 1-164-004-11 1-107-823-11 1-162-966-11 1-162-927-11 1-164-004-11 1-164-004-11 1-164-004-11 1-126-963-11 1-164-222-91 1-126-933-11 1-164-222-91 1-126-933-11 DESCRIPTION ELECT 10UF CERAMIC CHIP 0. 022UF FILM 0. 1UF CERAMIC CHIP 0. 1UF ELECT 47UF ELECT CERAMIC CERAMIC CERAMIC CERAMIC CHIP CHIP CHIP CHIP 47UF 0. 1UF 0. 047UF 0. 01UF 0. 001UF REMARK 20. 00% 10. 00% 5. 00% 10. 00% 20. 00% 50V 25V 100V 16V 25V ELECT 47UF CERAMIC CHIP 0. 22UF FILM 0. 01UF CERAMIC CHIP 0. 0033UF CERAMIC CHIP 0. 047UF CERAMIC CERAMIC CERAMIC FILM CERAMIC CERAMIC ELECT CERAMIC CERAMIC CERAMIC CHIP 0. 1UF CHIP 0. 1UF CHIP 100PF 0. 1UF CHIP 0. 1UF CHIP 0. 047UF 10UF CHIP 0. 01UF CHIP 220PF CHIP 0. 1UF 20. 00% 25V 25V 10. 00% 16V 10. 00% 25V 10. 00% 50V 10. 00% 16V 20. 00% 16V 20. 00% 16V 20. 00% 16V 20. 00% 10V 20. 00% 20. 00% 20. 00% 20. 00% 20. 00% 20. 00% 20. 00% 20. 00% 20. 00% 20. 00% 16V 10V 16V 16V 16V 16V 16V 25V 16V 16V CERAMIC CHIP 0. 47UF ELECT 100UF ELECT 470UF ELECT 100UF ELECT 470UF ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT 100UF 470UF 100UF 100UF 100UF 100UF 470UF 47UF 100UF 100UF FILM 0. 0047UF FILM 0. 015UF FILM 0. 0047UF CERAMIC CHIP 0. 1UF FILM 0. 033UF ELECT ELECT ELECT CERAMIC CERAMIC CHIP 10UF 10UF 330UF 470PF 0. 01UF 5. 00% 630V 5. 00% 630V 5. 00% 630V 25V 5. 00% 50V 20. 00% 20. 00% 20. 00% 10. 00% 10. 00% 10. 00% 20. 00% 20. 00% 10. 00% 10. 00% 10. 00% 10. 00% 20. 00% 20. 00% 20. 00% 10. 00% 10. 00% 10. 00% 10. 00% 20. 00% 50V 50V 25V 500V 50V 400V 25V 50V 50V 100V 100V 100V 50V 50V 50V 16V 25V 16V 16V 50V ELECT 100UF ELECT 47UF CERAMIC CHIP 0. 22UF CERAMIC CHIP 22PF CERAMIC CHIP 0. 47UF CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP 0. 1UF 0. 1UF 0. 1UF 0. 1UF 0. 1UF 0. 1UF 0. 1UF 0. 1UF 0. 1UF 0. 47UF 0. 0022UF 100PF 0. 1UF 0. 1UF 0. 1UF 20. 00% 16V 20. 00% 25V 25V 5. 00% 50V 10. 00% 16V 10. 00% 10. 00% 10. 00% 10. 00% 10. 00% 10. 00% 10. 00% 10. 00% 10. 00% 10. 00% 10. 00% 5. 00% 10. 00% 10. 00% 10. 00% 25V 25V 25V 25V 25V 25V 25V 25V 25V 16V 50V 50V 25V 25V 25V MYLAR 0. 001UF ELECT 330UF ELECT 100UF CERAMIC CHIP 0. 01UF MYLAR 0. 22UF MYLAR MYLAR ELECT ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC ELECT CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP 0. 1UF 0. 47UF 10UF 4. 7UF 4. 7UF 0. 1UF 0. 01UF 0. 1UF 0. 1UF 1UF 0. 047UF 0. 1UF 1UF 100PF 0. 1UF 10. 00% 16V 10. 00% 25V 16V 5. 00% 50V 25V ELECT 4. 7UF CERAMIC CHIP 0. 22UF ELECT 100UF CERAMIC CHIP 0. 22UF ELECT 100UF 20. 00% 50V 25V 20. 00% 16V 25V 20. 00% 16V H5 D2 A REF. NO. C7059 C7060 C7061 C7062 C7063 C7064 C7065 C7067 C7068 C7069 C7070 C7071 PART. NO 1-126-933-11 1-164-222-91 1-164-004-11 1-164-004-11 1-164-004-11 1-126-947-11 1-164-222-91 1-126-947-11 1-164-222-91 1-162-919-11 DESCRIPTION ELECT 100UF CERAMIC CHIP 0. 22UF CERAMIC CHIP 0. 1UF CERAMIC CHIP 0. 1UF CERAMIC CHIP 0. 1UF ELECT 47UF CERAMIC CHIP 0. 22UF ELECT 47UF CERAMIC CHIP 0. 22UF CERAMIC CHIP 22PF REMARK 20. 00% 16V 25V 10. 00% 25V 10. 00% 25V 10. 00% 25V 20. 00% 25V 25V 20. 00% 25V 25V 5. 00% 50V 5. 00% 50V 5. 00% 50V REF. NO. D3001 D3003 D3005 D3007 D3008 D3009 D3011 D3013 D3015 D3017 D3018 D3019 D3021 D3023 D3024 D3026 D3028 D3201 D5101 D5103 D5104 D5300 D5303 D5304 D5305 D5306 D5307 D5309 D5310 D5400 D5401 D5404 D5405 D5406 D5407 D5804 D5807 D5809 D5811 D5812 D5813 D6200 D7004 D7006 PART. NO 8-719-929-15 8-719-929-15 8-719-929-15 8-719-109-89 8-719-109-89 8-719-929-15 8-719-929-15 8-719-929-15 8-719-929-15 8-719-109-89 8-719-109-89 8-719-929-15 8-719-929-15 8-719-109-89 8-719-929-15 8-719-929-15 8-719-929-15 8-719-109-89 8-719-050-38 8-719-110-88 8-719-109-89 8-719-081-97 8-719-081-97 8-719-081-97 8-719-991-33 8-719-302-43 8-719-987-87 8-719-081-97 8-719-081-97 8-719-982-03 8-719-050-38 8-719-110-41 8-719-908-03 8-719-081-97 8-719-081-97 8-719-109-89 8-719-929-15 8-719-050-38 8-719-081-97 8-719-081-97 8-719-081-97 8-719-063-70 8-719-929-15 1-216-809-11 DESCRIPTION DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE HZS9. 1NB2 HZS9. 1NB2 HZS9. 1NB2 RD5. 6ESB2 RD5. 6ESB2 HZS9. 1NB2 HZS9. 1NB2 HZS9. 1NB2 HZS9. 1NB2 RD5. 6ESB2 RD5. 6ESB2 HZS9. 1NB2 HZS9. 1NB2 RD5. 6ESB2 HZS9. 1NB2 HZS9. 1NB2 HZS9. 1NB2 RD5. 6ESB2 M1MA152WK-T1 RD39ES-B2 RD5. 6ESB2 MMDL914T1 MMDL914T1 MMDL914T1 1SS133T-77 EL1Z ERA82-009 MMDL914T1 MMDL914T1 MTZJ-3. 6A M1MA152WK-T1 RD15ES-B2 GP08D MMDL914T1 MMDL914T1 RD5. 6ESB2 HZS9. 1NB2 M1MA152WK-T1 MMDL914T1 MMDL914T1 REMARK 1-162-919-11 CERAMIC CHIP 22PF 1-162-919-11 CERAMIC CHIP 22PF < CONNECTOR > CN0101 CN0102 CN0103 CN1000 CN1001 CN2000 CN2500 CN2501 CN2502 CN5002 CN5100 CN5200 CN5801 CN6200 CN6202 CN6203 CN7000 CN7001 CN8001 1-823-330-11 *1-564-520-11 *1-564-507-11 1-770-130-11 1-766-296-21 *1-564-512-11 *1-564-506-11 *1-564-507-11 *1-564-509-11 *1-564-510-11 *1-564-506-11 *1-564-506-11 *1-764-333-11 *1-564-507-11 *1-564-516-11 1-695-915-11 *1-564-508-11 *1-564-512-11 1-766-281-11 < DIODE > CONNECTOR, BOARD TO BOARD 40P PLUG, CONNECTOR 5P PLUG, CONNECTOR 4P CONNECTOR (SQUARE TYPE) 21P CONNECTOR, DUAL SCART PLUG, PLUG, PLUG, PLUG, PLUG, PLUG, PLUG, PLUG, PLUG, PLUG, CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR CONNECTOR 9P 3P 4P 6P 7P 3P 3P 10P 4P 13P TAB (CONTACT) PLUG, CONNECTOR 5P PLUG, CONNECTOR 9P PIN, CONNECTOR (PC BOARD) 8P D0101 D0104 D0110 D0111 D0112 D0113 D1006 D2014 D2015 D2016 D2018 D2019 D2500 D2502 D2503 8-719-921-88 8-719-109-89 8-719-109-89 8-719-929-15 8-719-921-88 8-719-921-88 8-719-109-89 8-719-929-15 8-719-929-15 8-719-050-38 8-719-929-15 8-719-929-15 8-719-050-38 8-719-109-89 8-719-050-38 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE MTZJ-13B RD5. 6ESB2 RD5. 6ESB2 HZS9. 1NB2 MTZJ-13B MTZJ-13B RD5. 6ESB2 HZS9. 1NB2 HZS9. 1NB2 M1MA152WK-T1 HZS9. 1NB2 HZS9. 1NB2 M1MA152WK-T1 RD5. 6ESB2 M1MA152WK-T1 DIODE MMDL914T1 DIODE D1NL20U DIODE HZS9. 1NB2 RES-CHIP 100 5% 1/10W < FERRITE BEAD > FB3001 1-414-760-21 FERRITE 0UH - 62 - A REF. NO. [. . . ]