User manual SWISHER LS422X

[. . . ] swisherinc. com OWNER'S MANUAL MODEL NO. LS422X STARTING SERIAL #: L206-010001 LOG SPLITTER Safety Assembly Operation Service and Adjustment Repair Parts PHONE 660-747-8183 Made In The IMPORTANT Read and follow all Safety Precautions and Instructions before operating this equipment. Rev. 06-010 1602 CORPORATE DRIVE, WARRENSBURG, MISSOURI 64093 FAX 660-747-8650 Manufacturing quality lawn care equipment since 1945 11421 USA LIMITED WARRANTY The manufacturer's warranty to the original consumer purchaser is: This product is free from defects in materials and workmanship for a period of ONE (1) year from the date of purchase by the original consumer purchaser. We will repair or replace, at our discretion, parts found to be defective due to materials or workmanship. [. . . ] Someone could accidentally activate the ram and be injured. Both ends of the log should be cut as squarely as possible to prevent the log from sliding out of the splitter during operation. Log length should be kept to 24" or less. NEVER operate your splitter while it is attached to the tow vehicle. BEFORE towing, be certain that the splitter is securely attached to the towing vehicle and that the support leg, beam and cylinder are secured in there respective towing positions. NEVER allow persons to ride on splitter. DO NOT carry any cargo or wood on your splitter. DO NOT loosen or remove any hydraulic fitting, line or reservoir cap while your splitter or engine is running. Fluid escaping from a very small hole can almost be invisible. See maintenance section for instructions. IF injured by escaping fluid, see a doctor at once. Serious infection or reaction can develop if proper medical treatment is not administered immediately. DO NOT operate your splitter in poor mechanical condition or when it is need of repair. ALWAYS disconnect the spark plug wire and place the wire where it cannot contact the spark plug, to prevent accidental starting the engine when setting up, transporting, adjusting or repairing. · · · · · · · · · · · · · 4 ASSEMBLY This log splitter has been partially assembled at the factory. Refer to the drawings and part lists should it become necessary to disassemble the unit for repair or replacement of parts. If you believe you have a damaged part please contact customer service immediately at 1-800-222-8183. WARNING: Exercise extreme caution, as parts are very heavy. Sufficient persons or mechanical handling equipment should be used. Refer to uncrating and assembly instructions for assembly procedures. OPERATION INTENDED USE: This log splitter is intended and designed to only split wood. Doing so can cause injury or VOID THE WARRANTY. IMPORTANT: This unit is shipped with oil but without gasoline in the engine. After assembly, see separate Engine Manual for proper fuel and oil recommendations. WARNING: DO NOT START OR RUN THE LOG SPLITTER WITHOUT OIL IN THE ENGINE AND HYDRAULIC RESERVOIR. [. . . ] To keep your splitter in top working condition perform all recommended maintenance procedures before you use your splitter. If the wedge becomes dull or nicked a grinder or sharpening tool can be used to sharpen it. Completely drain the fuel tank prior to storage. Always store gasoline in an approved, tightly sealed container. [. . . ]