User manual SWISHER ZMAX ZT2560

[. . . ] ZT2560 ZT2560 25 HP ­ 60" CUT CELEBRATING OVER 60 YEARS OF INNOVATION 1945 - 2006 1602 CORPORATE DRIVE, P. O. BOX 67, WARRENSBURG, MISSOURI 64093 PHONE 660-747-8183 FAX 660-747-8650 Made In The Manufacturing quality lawn care equipment since 1945 USA Rev. 06-046 OWNER'S MANUAL STARTING SERIAL # L506-017001 11849 LIMITED WARRANTY The manufacturer's warranty to the original consumer purchaser is: This product is free from defects in materials and workmanship for a period of two (2) years from the date of purchase by the original consumer purchaser. We will repair or replace, at our discretion, parts found to be defective due to materials or workmanship. [. . . ] On uneven terrain, the machine can tip more easily. Drive slowly and use small movements of the steering controls. It is slippery, and the tires can loose their grip, so that the machine slides. Do not try to stabilize the machine by putting a foot on the ground. Remember The operator is responsible for avoiding dangers or accidents. Children Serious accidents may occur if you fail to be on guard for children in the area of the machine. Children are often attracted to the machine and mowing work. Wear heavy, thick gloves when holding onto blade. For best results, mower blades must be kept sharp. Replace bent or damage blades. Safely raise front of mower. SEE WARNING Hold or block blade from turning. Replace blade, (SEE SPECIFICATIONS). WARNING When it is necessary to raise the mower for any repair or service, use jackstands to provide adequate support. DO NOT rely on hydraulic or mechanical jacks Battery WARNING The battery contains sulfuric acid and electrolytes which are poisonous and corrosive. The battery is a maintenance-free battery and the fluid level cannot be checked. Charge battery if needed. To clean battery and terminals Remove terminal guard. Disconnect the BLACK battery cable first, then the RED battery cable and remove the battery. Rinse the battery with plain water and dry. Clean terminals and battery cable ends with wire brush until shiny. Coat terminals with grease or petroleum jelly Reinstall battery Reconnect the battery cables 13 CUSTOMER RESPONSIBILITIES V-Belts Check V-belts for deterioration and wear after 100 hours of operation and replace if necessary. Replace belts if they begin to slip from wear. SEE SPECIFICATION for belt part numbers and SERVICE section of this manual for instructions on how to replace the belt. Engine REFER TO YOUR ENGINE OWNERS MANUAL Overall Unit Care Reduce the risk of fire by removing grass, leaves, and other debris that may have accumulated on the machine. Allow the machine time to cool before cleaning or putting it in storage. Wash mower periodically. Clean above and below deck. Keep all electrical connections clean and tight. Driving and Transport on Public Roads Check applicable road traffic regulations before driving and transporting on public roads. If the machine is transported, you should always use approved fastening equipment and ensure that the machine is well anchored. The cutting deck should also be lowered to the lowest position and the steering levers should be in the outward position, so that the parking brake is engaged. 14 CUSTOMER RESPONSIBILITIES MAINTENANCE SCHEDULE Before Each Use Check Brake Operation Check Tire Pressure Check Operator Presence Parking Brake Check for Loose Fasteners Sharpen/Replace Mower Blades Check Battery Clean Battery & Terminals Check Belts Check Engine Oil Change Engine Oil w/ filter Change Engine Oil w/o filter Replace Oil Filter 8 Hours 25 Hours 50 Hours 100 Hours Season Before Storage X X X X X X X X X3 X X X X X X X X X1, 2 X1, 2 X1, 2 X2 X X2 X X X Clean Air Filter Inspect Muffler Clean Engine Cooling Fins Replace Spark Plug Replace Fuel Filter 1 ­ Change more often when operating under a heavy load or in high ambient temperatures 2 ­ Service more often when operating in dirty or dusty conditions 3 ­ Replace blades more often when mowing in sandy soil 15 OPERATION FEATURES 9 7 10 6 1. [. . . ] If you have a question regarding your warranty rights and responsibilities, you should contact the Swisher Mower Service representative at 1-800-222-8183. WARRANTY COMMENCEMENT DATE: The warranty period begins on the date the Power Equipment Is purchased. LENGTH OF COVERAGE: This warranty shall be for a period of two (2) years from the initial date of purchase. WHAT IS COVERED: Warranted parts include the Liquid fuel line, fuel line connectors, and fuel line clamps. [. . . ]