User manual WHIRLPOOL ADN 640 INSTRUCTION FOR USE

[. . . ] 0806_GB_42 Instructions for installation, use e maintenance GAS PASTA COOKER ADN 640 04/2008 CHARACTERISTICS Supplied by: Date: Customer Service: FAX e-mail 0806_GB_42 - GAS PASTA COOKER 04/2008 2 · 12 INDEX 1 2 3 Diagram Characteristics of the appliances Technical data 4 5 5 6 6 6 6 6 6 6 6 6 6 7 7 7 7 7 7 8 8 8 8 8 8 8 8 9 9 9 9 9 9 9 10 10 10 10 10 10 10 10 10 10 11 11 11 11 4 Installation instructions 4. 1 Safety rules 4. 2 Structure, framework and safety devices of the appliances 4. 3 Assembly 4. 3. 1 Installation premises 4. 3. 2 Statutory regulations and technical requirements 4. 3. 3 Installation 4. 3. 4 Gas connection 4. 3. 5 Water connection 4. 3. 6 Smoke extraction 5 Operation preparation 5. 1 Preparation and Start-up 5. 1. 1 Start-up 5. 1. 2 Check of power 5. 1. 3 Checking the input pressure 5. 1. 4 Power check with volumetric method 5. 1. 5 Power check for operation with liquid gas 5. 1. 6 Operation control 5. 1. 7 Check of pilot flame 5. 1. 8 Checking the primary air 5. 1. 9 Operator training 5. 1. 10 Conversion and adjustment 5. 1. 11 Replacement of burner injector 5. 1. 12 Replacement of burner pilot injector 5. 1. 13 Setting reduced capacity power 5. 2 Maintenance 5. 3 Replacing parts 5. 3. 1 Gas cock 5. 3. 2 Thermocouple 5. 3. 3 Plug 5. 3. 4 Burner 6 Instructions for use 6. 1 Safety, cleaning and repair rules 6. 2 Start-up 6. 2. 1 Lighting pilot burner 6. 2. 2 Lighting the main burner and temperature adjustment 6. 3 Cleaning and taking care of the machine 6. 4 Turning the appliance off in case of breakdown 6. 4. 1 What to do in case of failure 6. 4. 2 What to do in case of prolonged period of disuse 6. 5 Appliance care and frequency of maintenance 6. 6 Recommendations for handling “stainless steel” industrial kitchens 6. 6. 1 Useful information on “stainless steel” 6. 6. 2 Warnings and advice for maintenance of “stainless steel” appliances 6. 6. 3 WEEE Directive 0806_GB_42 - GAS PASTA COOKER 04/2008 3 · 12 1 - DIAGRAM ADN 640 400 700 60 0 Water drainpipe 1"GC female Water drainpipe 1"GC female 408 305 305 150 117 128 55 04/2008 Gas 1/2" 87 45 310 45 Water load pipe Ø12 545 Data plate Water load pipe Ø12 132 143 700 Gas 1/2" 45 400 32 Data plate 0806_GB_42 - GAS PASTA COOKER 4 · 12 678 2 - CHARACTERISTICS OF THE APPLIANCES These appliances are used for professional purposes. Installation, repair and use must be carried out by expert personnel. These instructions for installation are for our gas pasta cooker set up for the category in the table 1 on pag. The data plate is located on the appliance, see diagram. [. . . ] 2), unscrew the nut fixing the injector-holder (pos. 2), and pull off from the burner, unscrew the screws (pos. 2) fixing the burner to the combustion chamber, pull down the burner (pos. 2) to free it from the rear centering pin, pull off and put in a new piece in the reverse order. After the replacement check the seal using a leack detector spray. 0806_GB_42 - GAS PASTA COOKER 04/2008 9 · 12 6 - INSTRUCTIONS FOR USE 6. 1 Safety, cleaning and repair rules • This appliance is used for the preparation of meals at industrial level. Usage and cleaning can be carried only by expert personnel. Maintenance and repair can be carried out only by skilled technical personnel. • These indications must be communicated to all those concerned during internal training. This appliance must be constantly watched over when being used!• Grease and overheated oil can catch fire. Use this appliance only under constant control. Never use water to put out grease or oil!• Do not leave the burners running. • Parts of the appliance and attachments exposed to food must be cleaned with detergents and rinsed thoroughly with potable water. • Do not clean the appliance using water jets or steam, whether direct or pressurized!• If the room is being cleaned with water/steam jets or high-pressure equipment, it is necessary to switch off the appliance first!• Before starting to clean the appliance, disconnect from the mains. • Do not use inflammable liquid to clean the appliance. • Repairs may be carried out only by skilled personnel. • During repairs, the appliance must undergo voltage omnipolar insulation (local switch, i. e. • Noise emission values of the appliance in operation are below 70dB (A). This value is compulsory according to certain national safety standards. [. . . ] Failure to do so shall result in the user being subject to the penalties prescribed by the legislation in force on waste. Suitable separated collection so that the unit no longer used can be sent off for environmentally compatible recycling, treatment and disposal helps avoid possible negative effects on the environment and on health and facilitates the recycling of the product's component materials. For more detailed information on available collection systems, contact the local waste disposal service or the shop you purchased the unit from. Producers and importers fulfil their responsibility for environmentally compatible recycling, treatment and disposal both directly and by joining a collective scheme. 6. 6. 2 Warnings and advice for maintenance of “stainless steel” appliances • “Stainless” steel equipment surfaces must be kept clean and in contact with air at all times. [. . . ]