User manual YAMAHA BW100-2006

[. . . ] 1 2 3 4 5 6 7 OWNER'S MANUAL8 9 YW100E 4VP-F8199-E2 INTRODUCTION EAU00001 Welcome to the Yamaha world of motorcycling!As the owner of a BW'S100, you are benefiting from Yamaha's vast experience in and newest technology for the design and the manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all your BW'S100's advantages. The owner's manual does not only instruct you in how to operate, inspect and maintain your scooter, but also in how to safeguard yourself and others from trouble and injury. [. . . ] 9 Check bearing for looseness or damage. 9 Check bearing play and steering for roughness. 9 Lubricate with lithium-soap-based grease. 9 Make sure that all nuts, bolts and screws are properly tightened. 9 Lubricate. Whenever worn to the limit Whenever worn to the limit Every 4 years 5 * Rear brake 6 * Brake hose 7 * Wheels 8 * Tires 9 * Wheel bearings 10 * Steering bearings 11 * Chassis fasteners 12 Sidestand/ centerstand Every 24, 000 km 6-3 PERIODIC MAINTENANCE AND MINOR REPAIR No. ITEM CHECKS OR MAINTENANCE JOB 9 Check operation. 9 Check operation and shock absorber for oil leakage. 9 Check oil level and vehicle for oil leakage. 19 * V-belt 20 * Front and rear brake switches 21 Moving parts and cables 9 Replace. Every 10, 000 km ODOMETER READING(km) 1, 000 6, 000 12, 000 18, 000 24, 000 ANNUAL CHECK 13 * Sidestand switch 14 * Front fork 15 * Rear shock absorber assembly 16 * Carburetor 17 * Autolube pump 18 Final gear oil 22 * Lights, signals and switches 6-4 PERIODIC MAINTENANCE AND MINOR REPAIR * Since these items require special tools, data and technical skills, they should be serviced by a Yamaha dealer. EAU01450 NOTE: 8 The air filter needs more frequent service if you are riding in unusually wet or dusty areas. 8 Hydraulic brake system 9 When disassembling the master cylinder or caliper cylinder, always replace the brake fluid. Check the brake fluid level regularly and fill as required. 9 Replace the oil seals on the inner parts of the master cylinder and caliper cylinder every two years. 9 Replace the brake hoses every four years or if cracked or damaged. 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR 1 1 1 2 1. Panel EAU01139 1. Protection bar EAUT0483 1. Cowling A Cowling and panel removal and installation The cowlings and panels illustrated need to be removed to perform some of the maintenance described in this chapter. Refer to this section each time a cowling or panel has to be removed or reinstalled. Cowling A To remove 1. Remove the front protection bar by removing the bolts. 2. Remove the cowling screws, disconnect the headlight leads coupler and remove the cowling. 6-6 PERIODIC MAINTENANCE AND MINOR REPAIR 1 1 1 1. Headlight leads coupler 1. Panel B EAU01315 1. Spark plug wrench EAUT1529 To install 1. Place the cowling in the original position and install the screws. Place the front protection bar in the original position and install the bolts. Panel B To remove Remove the screws. To install Place the panel in the original position and install the screws. Spark plug Removal 1. (Refer to page 6-7 for removal and installation procedures. ) 2. [. . . ] Only for scooters equipped with a fuel cock which has an "OFF" position: Turn the fuel cock to "OFF". Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from rusting and the fuel from deteriorating. Perform the following steps to protect the cylinder, piston rings, etc. Remove the spark plug cap and spark plug. [. . . ]