User manual YAMAHA FJR1300-2002

[. . . ] OWNER'S MANUAL FJR1300 5JW-28199-E1 EAU03338 INTRODUCTION Welcome to the Yamaha world of motorcycling!As the owner of an FJR1300, you are benefiting from Yamaha's vast experience and newest technology regarding the design and manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all advantages of your FJR1300. The owner's manual does not only instruct you in how to operate, inspect and maintain your motorcycle, but also in how to safeguard yourself and others from trouble and injury. [. . . ] Tightening torque: Spark plug: 12. 5 Nm (1. 25 m·kgf) 6-8 PERIODIC MAINTENANCE AND MINOR REPAIR EAU04465 Engine oil and oil filter cartridge The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter cartridge replaced at the intervals specified in the periodic maintenance and lubrication chart. Place the motorcycle on the centerstand. 6 NOTE: Make sure that the motorcycle is positioned straight up when checking the oil level. A slight tilt to the side can result in a false reading. _ _ 1. Wait a few minutes until the oil settles, and then check the oil level through the check window located at the bottom-left side of the crankcase. NOTE: The engine oil should be between the minimum and maximum level marks. _ _ 2. Start the engine, warm it up for several minutes, and then turn it off. 4. If the engine oil is below the minimum level mark, add sufficient oil of the recommended type to raise it to the correct level. To change the engine oil (with or without oil filter cartridge replacement) 1. Start the engine, warm it up for several minutes, and then turn it off. Place an oil pan under the engine to collect the used oil. Remove the engine oil filler cap and drain bolt to drain the oil from the crankcase. NOTE: Skip steps 4­6 if the oil filter cartridge is not being replaced. _ _ 6-9 PERIODIC MAINTENANCE AND MINOR REPAIR 1. Remove the oil filter cartridge with an oil filter wrench. NOTE: An oil filter wrench is available at a Yamaha dealer. _ _ _ _ 5. Apply a thin coat of engine oil to the O-ring of the new oil filter cartridge. NOTE: Make sure that the O-ring is properly seated. 1. Install the new oil filter cartridge, and then tighten it to the specified torque with a torque wrench. 6 Tightening torque: Oil filter cartridge: 17 Nm (1. 7 m·kgf) 7. Install the engine oil drain bolt, and then tighten it to the specified torque. 6-10 PERIODIC MAINTENANCE AND MINOR REPAIR ECA00105 EC000067 Tightening torque: Engine oil drain bolt: 43 Nm (4. 3 m·kgf) 8. Add the specified amount of the recommended engine oil, and then install and tighten the oil filler cap. Oil quantity: Without oil filter cartridge replacement: 3. 8 L With oil filter cartridge replacement: 4L Total amount (dry engine): 4. 9 L _ CAUTION: G In order to prevent clutch slippage (since the engine oil also lubricates the clutch), do not mix any chemical additives with the oil or use oils of grade "CD" or higher. [. . . ] 6-7 Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1 Speedometer. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3 Starting the engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1 Start switch. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]