User manual YAMAHA FZ6-N-2007

[. . . ] OWNER'S MANUAL FZ6-NA 5S3-28199-E0 EAU26943 DECLARATION of CONFORMITY We Company: MORIC CO. , LTD. Address: 1450-6 Mori Mori-Machi Shuchi-gun Shizuoka 437-0292 Japan Hereby declare that the product: Kind of equipment: IMMOBILIZER Type-designation: 5SL-00 is in compliance with following norm(s) or documents: R&TTE Directive(1999/5/EC) EN300 330-2 v1. 1. 1(2001-6), EN60950-1(2001) Two or Three-Wheel Motor Vehicles Directive(97/24/EC: Chapter 8, EMC) Place of issue: Shizuoka, Japan Date of issue: 1 Aug. Contents To change contact person and integrate type-designation. 1 Version up the norm of EN60950 to EN60950-1 2 Date 9 Jun. [. . . ] · Adjust engine idling speed and synchronization. · Check oil level and vehicle for oil leakage. Every 50000 km Every 800 km and after washing the motorcycle or riding in the rain 13 Drive chain 14 * Steering bearings Every 20000 km 6 15 * Chassis fasteners 16 Sidestand 17 * Sidestand switch 18 * Front fork Shock absorber assem19 * bly 20 * Fuel injection 21 22 Engine oil Engine oil filter cartridge 6-3 PERIODIC MAINTENANCE AND MINOR REPAIR ODOMETER READING (× 1000 km) NO. ITEM CHECK OR MAINTENANCE JOB 1 23 * Cooling system 24 * 25 Front and rear brake switches Moving parts and cables Throttle grip housing and cable · Check coolant level and vehicle for coolant leakage. · Adjust the throttle cable free play if necessary. · Lubricate the throttle grip housing and cable. · Check the air cut-off valve, reed valve, and hose for damage. · Replace the entire air induction system if necessary. · Check the screw clamp for looseness. 10 20 30 40 ANNUAL CHECK Every 3 years 26 * 27 * Air induction system Muffler and exhaust pipe Lights, signals and switches 28 * 29 * 6 EAU18680 NOTE: G Air filter · This model's air filter is equipped with a disposable oil-coated paper element, which must not be cleaned with compressed air to avoid damaging it. · The air filter element needs to be replaced more frequently when riding in unusually wet or dusty areas. G Hydraulic brake service · Regularly check and, if necessary, correct the brake fluid level. 6-4 PERIODIC MAINTENANCE AND MINOR REPAIR · Every two years replace the internal components of the brake master cylinders and calipers, and change the brake fluid. · Replace the brake hoses every four years and if cracked or damaged. 6 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18751 EAU19642 Removing and installing the panel The panel shown needs to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time the panel needs to be removed and installed. 1. Bolt Checking the spark plugs The spark plugs are important engine components, which should be checked periodically, preferably by a Yamaha dealer. Since heat and deposits will cause any spark plug to slowly erode, they should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plugs can reveal the condition of the engine. The porcelain insulator around the center electrode of each spark plug should be a medium-to-light tan (the ideal color when the vehicle is ridden normally), and all spark plugs installed in the engine should have the same color. If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. If a spark plug shows signs of electrode erosion and excessive carbon or other deposits, it should be replaced. Specified spark plug: NGK/CR9EK 6-6 To install the panel 1. [. . . ] 6-19 Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-10 K Key identification number. . . . . . . . . . . . . . . . . . . . . . . . 9-1 D Dimmer switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-10 Drive chain, cleaning and lubricating. . . . 6-24 Drive chain slack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]