User manual YAMAHA PHAZER 500-2000

[. . . ] If you have any questions concerning the operation or maintenance of your snowmobile, please consult a Yamaha dealer. To maintain the high quality and performance of this snowmobile, it is important that you and your Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. PZ50RTX PZ50GTX PZ50MTX PZ50VTX OWNER'S MANUAL ©2007 by Yamaha Motor Corporation, U. S. A. 1st Edition, April 2007 All rights reserved. [. . . ] · Replace if necessary. * Drive chain oil * Brake and parking brake Control cables Disc brake installation Slide runners Skis and ski runners * * * -- 64 62 43 Periodic maintenance INITIAL ITEM REMARKS 1 month or 800 km (500 mi) (40 hr) EVERY Seasonally or 4000 km (2500 mi) (200 hr) PAGE * Steering system · Check toe-out. · Check bearing assemblies for looseness. · Lubricate with specified grease. · Lubricate with specified grease. · Lubricate with specified grease. · Make sure that all nuts, bolts and screws are properly tightened. · Charge if necessary. 63 * Steering bearings Ski and front suspension Suspension component Fittings and fasteners -- * * 67 67 69 * Battery 69 * It is recommended that these items be serviced by a Yamaha dealer. NOTE: Brake system: G After disassembling the master cylinder or caliper cylinder, always change the brake fluid. Regularly check the brake fluid level and add fluid if necessary. G Replace the oil seals of the master cylinder and caliper cylinder every two years. G Replace the brake hose every four years, or if cracked or damaged. 44 Periodic maintenance ESU13000 ESU11761 Tool kit The owner's tool kit has the tools which are sufficient for most periodic maintenance and minor repairs. A torque wrench is also necessary to properly tighten nuts and bolts. Removing and installing the shroud and covers Shroud, front cover, and air filter case cover To open the shroud and remove the front cover and air filter case cover 1. Do not touch the hot muffler and engine during or immediately after operation. ECS00370 CAUTION: 1. Holder Make sure that all cables, leads, etc. , are routed properly before installing the shroud and covers. NOTE: When installing the covers, be sure to tighten all fasteners securely. ESU11780 Checking the spark plugs The spark plug is an important engine component and is easy to inspect. The condition of the spark plug can indicate the condition of the engine. Check the coloration on the white porcelain insulator around the center electrode. The ideal coloration at this point is a medium to a light tan color for a snowmobile that is being ridden normally. If a spark plug shows a distinctly different color, there could be something wrong with the engine. For example, a very white center electrode porcelain color could indicate an intake track air leak or carburetion problem for that cylinder. Do not attempt to diagnose such problems yourself. Instead, take the snowmobile to a Yamaha dealer for inspection and possible repairs. 1. Slot 2. Close the shroud. 48 Periodic maintenance You should periodically remove and inspect the spark plug because heat and deposits will cause a spark plug to slowly break down and erode. Consult a Yamaha dealer before changing to a different type of spark plug. [. . . ] 15 Shroud and covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 Shroud and covers, removing and installing . . . . . . . . . . . . . . . . . . . . . . . . . 45 Shroud latches (PZ50VT). . . . . . . . . . . . . . . . . . . . . . . . . 18 Ski damping force, adjusting (PZ50GT) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]