User manual YAMAHA PREMIUM EF2600

[. . . ] Generator OWNER'S MANUAL EF1600 EF2600 YG2600 LIT-19626-01-14 7NJ-28199-12 AE00002 INTRODUCTION Congratulations on your purchase of your new Yamaha. This manual will provide you with a good basic understanding of the operation and maintenance of this machine. If you have any questions regarding the operation or maintenance of your machine, please consult a Yamaha dealer. CODE AE00012 SERIAL No. IDENTIFICATION NUMBER RECORDS Record your Primary I. D. , and serial numbers in the spaces provided, to assist you in ordering spare parts from a Yamaha dealer. [. . . ] 9 This extension cord should be protected by a tough flexible rubber sheath (IEC 245) or the equivalent to withstand mechanical stresses. ­7­ EF1600/EF2600 AE00101 !3 q w !2 !3 CONTROL FUNCTION AE00102 DESCRIPTION i !0 o YG2600 793-015 !3 q w !2 !3 1 2 3 4 5 6 7 8 9 0 q w e Fuel tank Fuel tank cap Fuel cock Air filter cover Spark plug Muffler Choke lever Ground (Earth) terminal Oil filler cap Oil drain plug Recoil starter Fuel level gauge Carrying handles (shaded) i !0 o 793-016 !3 t !3 u e !1 r y 793-017 ­8­ EF1600 AE00104 w t CONTROL BOX 1 2 3 4 Engine switch Oil warning light Pilot light (YG2600) Voltage meter (EF1600/EF2600) 5 AC switch (N. F. B. ) 6 AC receptacle 7 G. F. C. I. receptacle 793-018 q r EF2600 y t w q 793-019 r YG2600 y t w q 793-020 e u y ­9­ AE00111 OIL WARNING SYSTEM When the oil level falls below the lower level, the engine stops automatically. Unless you refill with oil, the engine will not start again. NOTE: If the engine stalls or does not start, turn the engine switch to "ON" position and then pull the recoil starter. If the oil warning light flickers for a few seconds, the engine oil is insufficient. Add oil and restart. 700-027c AE00122 q w 763-084f ENGINE SWITCH The engine switch controls the ignition system. 1 7 "ON" Ignition circuit is switched on. The engine can be started. 2 5 "STOP" Ignition circuit is switched off. The engine will not run. q ON AE00131 OFF 763-095 AC SWITCH (N. F. B. ) The AC switch (Non-Fuse Breaker) turns off automatically when the load exceeds the generator rated output. 1 2 I 3 "ON" "OFF" ON cC w OFF 763-086c Reduce the load to the specified generator rated output if the AC switch (N. F. B. ) turns off. If it turns off again, consult your Yamaha dealer. ­ 10 ­ 1 AE00848 w 763-083 3 763-060 G. F. C. I. (Ground Fault Circuit Interrupter) 1 shuts off power to the protected receptacles if a ground fault (electrical leak) is detected. If the reset button 2 pops out 3, the equipment plugged into the receptacle may be faulty. If this happens, check the equipment carefully. If the equipment appears to be in good condition, press the reset button firmly until a click is heard. If the reset button pops out again, unplug the equipment immediately. Have the equipment inspected and repaired by a qualified repairperson before attempting to use it again. w TO REDUCE THE CHANCE OF ELECTRICAL SHOCK: 9 Do not attempt to operate equipment if the ground fault circuit interrupter reset button pops out repeatedly during use. 9 Test the ground fault circuit interrupter during the pre-operation checks according to the maintenance instructions on page 25. 9 Remember that only receptacles labeled "Ground Fault Protected" have ground fault circuit interrupter protection. ­ 11 ­ AE00845 PRE-OPERATION CHECK NOTE: Pre-operation checks should be made each time the generator is used. w The engine and muffler will be very hot after the engine has been run. Avoid touching the engine and muffler while they are still hot with any part of your body or clothing during inspection or repair. 741-001 AE00856 FUEL Make sure there is sufficient fuel in the tank. Recommended fuel: Unleaded gasoline Fuel tank capacity: Total: EF1600/EF2600 12. 0 L (2. 64 Imp gal, 3. 17 US gal) YG2600 19. 0 L (4. 18 Imp gal, 5. 02 US gal) Your Yamaha engine has been designed to use regular unleaded gasoline with a pump octane number ((R + M)/2) of 86 or higher, or research octane number of 91 or higher. 1 Fuel level gauge q 707-033a 707-001 "F" "E" Full Empty w 707-037 707-051 9 Fuel is highly flammable and poisonous. Check "SAFETY INFORMATION" (See page 5) carefully before refueling. 9 Do not fill above the top of the fuel filter or it may overflow when the fuel heats up later and expands. 9 After refueling, make sure the tank cap is tightened securely. ­ 12 ­ AE00222 ENGINE OIL Make sure the engine oil is at the upper level of the oil filler hole. [. . . ] 9 Type: 9 Gap: 791-001b 791-001d w 9 To prevent FIRE HAZARDS be sure fuel is not present in the spark plug area. 9 To prevent FIRE HAZARDS be sure to place the spark plug as far way as possible from the spark plug hole and carburetor area. 9 To prevent ELECTRIC SHOCK do not hold spark plug lead with hand while testing. J Engine starts. L Incorrect Replace or Adjust Gap. M OK Clean the spark plug. N Check the following O Clogged 9 Fuel cock clogging 9 Air cleaner element P OK clogging. Q Clean or Replace; Consult a Yamaha dealer. [. . . ]