User manual YAMAHA PRO

[. . . ] It also includes basic maintenance and inspection procedures. If you have any questions regarding the operation or maintenance of your vehicle, please consult a Yamaha dealer. WARNING _ Please read this manual carefully before operating this vehicle. Do not attempt to operate this vehicle until you have attained adequate knowledge of its controls and operating features. Regular inspections and careful maintenance, along with good operating techniques, will help ensure that you safely enjoy the capabilities and reliability of this vehicle. _ IMPORTANT MANUAL INFORMATION Particularly important information is distinguished in this manual by the following notations: The Safety Alert Symbol means ATTENTION! [. . . ] Have a Yamaha dealer repair as necessary for proper operation. 5-6 WARNING POTENTIAL HAZARD Checking operation of the accelerator pedal with the key in the main switch. WHAT CAN HAPPEN The engine can start and the vehicle can start moving when the accelerator pedal is depressed. HOW TO AVOID THE HAZARD Remove the key from the main switch before checking accelerator pedal operation. Tires Checking the tire pressure Use a tire pressure gauge to measure the tire pressure. WARNING POTENTIAL HAZARD Operating this vehicle with improper tires, or with improper or uneven tire pressure. WHAT CAN HAPPEN Use of improper tires on this vehicle, or operation of this vehicle with improper or uneven tire pressure, may cause loss of control, increasing your risk of accident. The tires listed below have been approved by Yamaha Motor Manufacturing Corporation of America for this model. Other tire combinations are not recommended. YXP700 Manufacturer Front Rear DURO DURO Size 20 × 10-8 / 4 PLY 20 × 10-8 / 4 PLY NOTE: Measure the tire pressure twice and use the second reading. Dust or dirt in the gauge could cause the first reading to be incorrect. 5-7 YXP1000 Manufacturer Front Rear DURO DURO Size 22 × 11-10 / 6 PLY 22 × 11-10 / 6 PLY 2. The tires should be set to the recommended pressure: G Recommended tire pressure Front 84 kPa (0. 84 kgf/cm2, 12 psi) Rear 84 kPa (0. 84 kgf/cm2, 12 psi) Check and adjust tire pressures when the tires are cold. Tire pressures must be equal on both sides. Tire pressure below the minimum specified could cause the tire to dislodge from the rim under severe riding conditions. The following are minimums: Front 70 kPa (0. 70 kgf/cm2, 10 psi) Rear 70 kPa (0. 70 kgf/cm2, 10 psi) 4. Choose a genuine Yamaha accessory, or one that is equivalent in design and quality. G G G Accessories should be rigidly and securely mounted. An accessory which can shift position or come off while you are operating could affect your ability to control the vehicle. Do not mount an accessory where it could interfere with your ability to control the vehicle. Examples include (but are not limited to) an object that limits your ability to turn the steering wheel or one that limits your view. Use extra caution when driving a vehicle with accessories. The vehicle may handle differently than it does without accessories. 6-4 EBU09600 Loading Cargo or a trailer can change the stability and handling of a vehicle. You must use common sense and good judgment when carrying cargo or towing a trailer. Keep the following points in mind: G Never exceed the weight limits shown. MAXIMUM LOADING LIMIT G Maximum cargo bed load: 113 kg (250 lb) (YXP700) 227 kg (500 lb) (YXP1000) G Tow hitch Tow weight (Including driver, passenger, vehicle cargo and trailer and trailer cargo): 227 kg (500 lb) (YXP700) 454 kg (1000 lb) (YXP1000) Tongue weight: 68 kg (150 lb) G G G G Choose a trailer hitch drawbar designed for use with a 5 cm (2 in) receiver. (See page 4-11 for more information. ) Do not exceed the maximum tongue weight. You can measure tongue weight with a bathroom scale. [. . . ] Cover the utility vehicle with a breathable cover and store it in a dry, well-ventilated area. Remove the battery from the utility vehicle and store it in a cool, dry place that stays between 0 °C (32 °F) and 30 °C (90 °F). Have the battery recharged every 60­90 days to keep it fully charged. The battery must be kept fully charged to avoid damage. NOTE: Batteries like the one supplied with your vehicle normally do not require you to check the water level inside the battery for the one year warranty period provided by the manufacturer. 9-2 1- SPECIFICATIONS 1 YXP700/YXP1000 2492 mm (98. 1 in) (YXP700) 3011 mm (118. 5 in) (YXP1000) 1232 mm (48. 5 in) (YXP700) 1289 mm (50. 7 in) (YXP1000) 1275 mm (50. 2 in) (YXP700) 1353 mm (53. 3 in) (YXP1000) 391 mm (15. 4 in) (YXP700) 463 mm (18. 2 in) (YXP1000) 1637 mm (64. 4 in) (YXP700) 1939 mm (76. 3 in) (YXP1000) 940 mm (37. 0 in) (YXP700) 1029 mm (40. 5 in) (YXP1000) 980 mm (38. 6 in) (YXP700) 1029 mm (40. 5 in) (YXP1000) 116 mm (4. 6 in) (YXP700) 143 mm (5. 6 in) (YXP1000) 2 3 4 5 6 7 8 9 10 11 12 13 14 Model Dimensions: Overall length Overall width Overall height (steering height) Height of floor Wheelbase Tread: Front Rear Ground clearance 10-1 Model Weight: Dry weight (without battery) Performance: Maximum speed Minimum turning radius Seating capacity Engine: Engine type Cylinder arrangement Displacement Bore x stroke Compression ratio Starting system Ignition system Spark plug type/manufacturer Spark plug gap Lubrication system YXP700/YXP1000 339 kg (747 lb) (YXP700) 452 kg (996 lb) (YXP1000) 24 km/h (15 mph) 3. 0 m (118. 1 in) (YXP700) 4. 3 m (169. 3 in) (YXP1000) 2 persons Air-cooled 4-stroke, OHV Forward-inclined single cylinder 357 cm3 85 x 63 mm (3. 30 x 2. 48 in) 8. 0:1 Electric starter TCI Magneto BPR2ES/NGK 0. 7­0. 8 mm (0. 028­0. 031 in) Splash 10-2 Model Engine oil: Type Recommended engine oil classification Quantity: Oil change Transmission: Type V-belt width and outer line length V-belt wear limit Transmission oil: Type Quantity Steering system: Type YXP700/YXP1000 YAMALUBE 4 (10W30) or SAE 10W30 API Service SE type or higher 0. 9 L (0. 79 Imp qt, 0. 95 US qt) V-belt automatic centrifugal 31 x 1010 mm (1. 22 x 39. 76 in) 27. 9 mm (1. 10 in) SAE 90 gear oil 0. 42 L (0. 37 Imp qt, 0. 44 US qt) Rack and pinion (YXP700) Worm and pin (YXP1000) 10-3 Model Brakes: Brake system YXP700/YXP1000 Mechanical drum brake on rear wheels with selfadjusters (YXP700) Mechanical drum brake on front and rear wheels with self-adjusters (YXP1000) Dual internal expanding shoe Leading/trailing shoes (self-adjusting) 20­25 mm (0. 79­0. 98 in) Foot type; with automatic release Type of brake Brake pedal freeplay linkage adjustment Parking brake: Type Wheel: Tire size: Front Rear Tire pressure: Front Rear Battery: 20 x 10­8 / 4 PLY (YXP700) 22 x 11­10 / 6 PLY (YXP1000) 20 x 10­8 / 4 PLY (YXP700) 22 x 11­10 / 6 PLY (YXP1000) 70­84 kPa (0. 70­0. 84 kgf/cm2, 10­12 psi) 70­84 kPa (0. 70­0. 84 kgf/cm2, 10­12 psi) BCI group 24 (52 AH, 20 hr rate) RC: minimum 75 min CCA: minimum 400A 10-4 Model Bulb voltage, wattage × quantity: Headlight Taillight Indicator light: Engine oil level warning light Specified fuses: Main fuse Headlight/signaling system fuse Auxiliary DC jack fuse YXP700/YXP1000 12 V, 30 W / 30 W × 2 Sealed beam × 2 12 V, 3. 4 W × 1 20 A 10 A 10 A 10-5 1- MAINTENANCE RECORD Copies of work orders and/or receipts for parts you purchase and install will be required to document maintenance done in accordance with the warranty. [. . . ]