User manual YAMAHA RS VECTOR-2005

[. . . ] SNOWMOBILE OWNER'S MANUAL RS90K RS90MK RS90RK RSG90K LIT-12628-02-38 8ES-28199-10 A ESU00286 1- MACHINE IDENTIFICATION Identification number records A. ENGINE NUMBER (PRIMARY ID): CZ-01E C. KEY NUMBER: C CZ-01E Record the frame number, engine number (Primary ID), and key number in the spaces provided for assistance when ordering spare parts from a Yamaha dealer. 1 The frame number is the seventeen-digit number stamped on the frame of the snowmobile. [. . . ] G If transporting the snowmobile in an open trailer or truck in areas where road salt is used, coat metal suspension surfaces lightly with oil or another protectant. This will help protect against corrosion. Be sure to clean the snowmobile when you get to your destination to remove any corrosive salts. 7-11 ESU00139 8- PERIODIC MAINTENANCE ESU00140 Periodic maintenance chart Regular maintenance is most important for best performance and safe operation. CD-01E Item Remarks Preoperation check (Daily) Initial 1 month or 800 km (500 mi) (40 hr) Every Seasonally or 3, 200 km (2, 000 mi) (160 hr) G Page Spark plugs Check condition. Replace if necessary. 8-4­8-5 Valve clearance Engine oil Engine oil filter cartridge Fuel Fuel filter Fuel line Check clearance. Adjust clearance when engine Every 40, 000 km (25, 000 mi) is cold. G G G Whenever operating condition (elevation/temperature) is changed. G G G G G G G G G G G 8-9 6-3­6-4 Every 20, 000 km 8-10­8-12 (12, 000 mi) 6-1­6-2 Engine coolant 6-4, 8-13­8-14 8-13 5-2, 6-5 Air bleed the cooling system if necessary. Tighten or replace gasket if necessary. Carburetor Engine stop switch Throttle override system (T. O. R. S. ) Throttle lever Exhaust system 5-8 5-3, 6-5 5-2, 6-5 It is recommended that these items be serviced by a Yamaha dealer. 8-1 Item Remarks Preoperation check (Daily) Initial 1 month or 800 km (500 mi) (40 hr) Every Seasonally or 3, 200 km (2, 000 mi) (160 hr) Page Drive guard V-belt Drive track and idler wheels Slide runners Check for cracks, bends or damage. Check deflection, and for wear and damage. Adjust free play and/or replace pads if necessary. Lubricate shaft with specified grease as required. Charge if necessary. G G G G G G G See NOTE on page 8-3. Every 1, 600 km (1, 000 mi) G G Initial at 500 km (300 mi) and every 800 km (500 mi) thereafter. G G G G G G G 5-10, 6-7 6-7, 8-15­8-17 6-8, 8-29­8-31 6-8 5-8­5-9, 6-6­6-7, 8-19­8-20 Brake and parking brake 8-20 Disc brake installation Drive chain oil Drive chain Skis and ski runners Steering system Strap (RS90M) 8-17­8-18 8-18 6-9 6-9 Lights Battery 6-9, 8-35 8-36 It is recommended that these items be serviced by a Yamaha dealer. 8-2 Item Remarks Preoperation check (Daily) Initial 1 month or 800 km (500 mi) (40 hr) Every Seasonally or 3, 200 km (2, 000 mi) (160 hr) G Page Check engagement and shift speed. Primary and second- Inspect weights/rollers and bushings for wear-for primary. ary clutches Inspect ramp shoes/bushings for wear-for secondary. Steering column bearing Ski and front suspension Suspension component Parking brake cable end and lever end/ throttle cable end Shroud latches Fittings and fasteners Tool kit and recommended equipment Lubricate with specified grease. Make sure that the shroud latches are hooked. Check for proper placement. Whenever operating elevation is changed. G G G G G G G G G G 5-10 6-11 6-11 8-34 8-34 8-34 It is recommended that these items be serviced by a Yamaha dealer. NOTE: @ Brake fluid replacement: 1. When disassembling the master cylinder or caliper cylinder, replace the brake fluid. Normally check the brake fluid level and add the fluid as required. On the inner parts of the master cylinder and caliper cylinder, replace the oil seals every two years. [. . . ] Apply suitable protectants to the exterior of the engine, drive track, and to other metal, plastic, and rubber parts. Battery Remove the battery from the snowmobile. Store it in a cool, dry place that is above 0 °C (32 °F), but less than 30 °C (90 °F). Check the condition of the battery once a month, and charge it as necessary. WARNING @ G G G @ Never smoke around the battery while it is being charged. [. . . ]