User manual YAMAHA T105-2002

[. . . ] OWNER'S MANUAL 5AV-F8199-E0 EAA00100 EAA20301 T105E OWNER'S MANUAL © 2001 by Yamaha Motor Co, Ltd. Manufacturing 1st edition, September 2001 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Co, Ltd. Printed in China INTRODUCTION Congratulations on your purchase of the Yamaha T105E. [. . . ] 16, 000 km*** Check balance/damage/runout/spoke tightness. Check bearing assembly for looseness/damage. Replace if damaged. EVERY 2, 000 km 2 2 2 2 2 2 2 2 2 2 39 INITIAL ITEM REMARKS 500 km 2, 000 km EVERY 4, 000 km 8, 000 km * Steering bearing * Front forks * Rear shock absorber Drive chain * Fittings/Fasteners * Centerstand and sidestand * Battery *: **: ***: Check bearing assembly for looseness. Check all chassis fitting and fasterners. Check that the breather pipe is working properly. Correct if necessary 2 2 2 2 2 EVERY 500 km 2 2 2 2 2 2 2 2 2 2 2 It is recommended that these items be serviced by a Yamaha dealer. (bearing type) Lithium soap base grease. (bush type) 40 EAH48201* Engine oil 1. Place the motorcycle on the centerstand. Warm up the engine for several minutes. EUU03901 1 Oil level gauge 2 Upper level 3 Lower level NOTE: Be sure the motorcycle is positioned straight up when checking the oil level. A slight tilt toward the side can result in false readings. With the engine stopped, wait a few minutes and then remove the oil level gauge. Wipe the oil level gauge off with a clean rag and insert it in the filler hole without screwing it in. 41 d. The oil level should be between the maximum and minimum marks. If the level is low, add sufficient oil to raise it to the proper level. Place an oil pan under the engine, and remove the oil level gauge. Remove the drain plug and drain the oil. q 1 Drain plug Tightening torque Drain plug 20 Nm (2. 0 m·kg) d. Reinstall the drain plug (make sure it is tight. ) 42 Recommended oil: See page 25 Oil quantity: Total amount: 1. 0 L Periodic oil change: 0. 8 L e. Fill engine with oil through the oil level gauge hole. EUU47700 cC 9 Do not put in any chemical additives or use oils with a grade of "CD (for Diesel engine)" or higher. Also, be sure not to use oils labeled "ENERGY CONSERVING II" or higher. Engine oil also lubricates the clutch and additives could cause clutch slippage. 9 Be sure no foreign material enters the crankcase. [. . . ] Substitution of a fuse of improper rating can cause extensive electrical system damage and possibly a fire. 62 EAJ50002 Troubleshooting Although Yamaha motorcycles receive a rigid inspection before shipment from the factory, trouble may occur during operation. If your motorcycle requires any repair, bring it to a Yamaha dealer. The skilled technicians at a Yamaha dealership have the tools, experience, and know-how to properly service your motorcycle. Use only genuine Yamaha parts on your motorcycle. [. . . ]