User manual YAMAHA TEO-S125-2000

[. . . ] OWNER'S MANUAL XN125 5MF-F8199-E0 EAU00001 INTRODUCTION Welcome to the Yamaha world of motorcycling!As the owner of a XN125, you are benefiting from Yamaha's vast experience and newest technology regarding the design and manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all advantages of your XN125. The owner's manual does not only instruct you in how to operate, inspect and maintain your scooter but also in , how to safeguard yourself and others from trouble and injury. [. . . ] Remove the oil filler bolt and drain bolt to drain the oil from the final 6 gear case. Install the final gear oil drain bolt, and then tighten it to the specified torque. Tightening torque: Final gear oil drain bolt: 22 Nm (2. 2 m·kg) PERIODIC MAINTENANCE AND MINOR REPAIR 5. Add the specified amount of the recommended final gear oil, and then install and tighten the oil filler bolt. Recommended final gear oil: Engine oil SAE 10W30 (API SE) Oil quantity: 0. 15 L EW000066 1 1 2 ZAUM0044 ZAUM0045 1. Coolant reservoir cap Coolant To check the coolant level 1. the WARNING Make sure that no foreign material 6 enters the final gear case. Make sure that no oil gets on the tire or wheel. Check the final gear case for oil leakage. If oil is leaking, check for the cause. 2. (See page 6-6 for cover removal and installation procedures. ) 3. Check the coolant level in the coolant reservoir. NOTE: The coolant should be between the minimum and maximum level marks. If the coolant is at or below the minimum level mark, open the reservoir cap, add coolant to the maximum level mark, and then close the reservoir cap. NOTE: · The coolant level must be checked on a cold engine since the level varies with engine temperature. · Make sure that the scooter is positioned straight up when checking the coolant level. A slight tilt to the side can result in a false reading. 6-13 PERIODIC MAINTENANCE AND MINOR REPAIR EW000067 Coolant reservoir capacity: 0. 35 L 5. Install the panel B. EC000080 EAUM0034 WARNING Never attempt to remove the radiator cap when the engine is hot. NOTE: The radiator fan is automatically switched on or off according to the coolant temperature in the radiator. If the engine overheats, see page 6-32 for further instructions. Air filter and V-belt case air filter elements The air filter and the V-belt case air filter elements should be cleaned at the intervals specified in the periodic maintenance and lubrication chart. Clean both filter elements more frequently if you are riding in unusually wet or dusty areas. CAUTION: If coolant is not available, use distilled water or soft tap water instead. Do not use hard water or salt water since it is harmful to the engine. · If water has been used instead of coolant, replace it with coolant as soon as possible, otherwise the engine may not be sufficiently cooled and the cooling system will not be protected against frost and corrosion. [. . . ] 5-4 Panel A . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6 Panel B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6 Periodic maintenance and lubrication chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2 Pre-operation check list . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]