User manual YAMAHA TT-R110E

[. . . ] Read this manual carefully before operating this vehicle. OWNER'S MANUAL TT-R110EY LIT-11626-22-53 5B6-28199-11 EAU10042 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. INTRODUCTION EAU41733 Congratulations on your purchase of the Yamaha TT-R110EY. This model is the result of Yamaha's vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. [. . . ] If oil is leaking, immediately turn the engine off and check for the cause. Turn the engine off, and then check the oil level and correct it if necessary. 1 2 1. Pull the sponge material and the mesh out. 4. Clean the mesh with solvent, and then wipe the solvent off. Clean the sponge material with solvent, and then squeeze the remaining solvent out. Use only a dedicated parts cleaning solvent. To avoid the risk of fire or explosion, do not use gasoline or solvents with a low flash point. [EWA10431] NOTICE: To avoid damaging the foam material, handle it gently and carefully, and do not twist or wring it. [ECA10511] 7-10 PERIODIC MAINTENANCE AND ADJUSTMENT mesh and the sponge material installed, otherwise the piston(s) and/or cylinder(s) may become excessively worn. [ECA15572] 1 1 6. Apply oil of the recommended type to the entire surface of the sponge material, and then squeeze the excess oil out. TIP The sponge material should be wet but not dripping. Recommended oil: Yamaha foam air filter oil or other quality foam air filter oil 1. Check the hoses at the bottom of the air filter case for accumulated dirt or water. Install the air filter case cover by installing the screws. TIP Make sure that the spark plug cable is routed as shown. 7. Insert the mesh and the sponge material into the air filter case. NOTICE: Make sure that the mesh and the sponge material are properly seated in the air filter case. The engine should never be operated without the 7-11 1 1. Air filter check hose PERIODIC MAINTENANCE AND ADJUSTMENT 2. If dirt or water is visible, remove the hoses, clean them, and then reinstall them. EAU40421 Cleaning the spark arrester The spark arrester should be cleaned at the intervals specified in the periodic maintenance and lubrication chart. EWA10980 1 2 WARNING G G Always let the exhaust system cool prior to touching exhaust components. Do not start the engine when cleaning the exhaust system. 1. Bolt TIP Make sure to select a well-ventilated area free of combustible materials to clean the spark arrester. Remove the tailpipe by removing the bolts, and then pulling it out of the muffler. 2. [. . . ] 7-28 Wheel (rear) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-29 Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-16 E Engine break-in. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-3 Engine idling speed. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-13 Engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]