User manual YAMAHA TTR110-2009

[. . . ] Read this manual carefully before operating this vehicle. Il convient de lire attentivement ce manuel avant la première utilisation du véhicule. Bitte lesen Sie diese Bedienungsanleitung sorgfältig durch, bevor Sie das Fahrzeug in Betrieb nehmen. OWNER'S MANUAL MANUEL DU PROPRIÉTAIRE BEDIENUNGSANLEITUNG TT-R110E(Y) 5B6-28199-81 YAMAHA MOTOR CO. , LTD. PRINTED ON RECYCLED PAPER IMPRIMÉ SUR PAPIER RECYCLÉ AUF RECYCLINGPAPIER GEDRUCKT PRINTED IN JAPAN 2008. 06-1. 1×1 CR (E, F, G) Read this manual carefully before operating this vehicle. OWNER'S MANUAL TT-R110E(Y) 5B6-28199-81-E0 EAU46231 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. EC Declaration of Conformity conforming to Directive 98/ 37/EC We, YAMAHA MOTOR CO. , LTD. [. . . ] Since heat and deposits will cause any spark plug to slowly erode, the spark plug should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plug can reveal the condition of the engine. Spark plug wrench 6 To install the panel 1. Place the panel in the original position, and then install the bolt. Install the seat. To check the spark plug 1. Check that the porcelain insulator around the center electrode of the spark plug is a medium-to-light tan (the ideal color when the vehicle is ridden normally). TIP If the spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 1 1. Remove the spark plug as shown, with the spark plug wrench included in the owner's tool kit. 6-7 PERIODIC MAINTENANCE AND ADJUSTMENT 2. Check the spark plug for electrode erosion and excessive carbon or other deposits, and replace it if necessary. Specified spark plug: NGK/CR6HSA 2. Clean the surface of the spark plug gasket and its mating surface, and then wipe off any grime from the spark plug threads. Install the spark plug with the spark plug wrench, and then tighten it to the specified torque. Tightening torque: Spark plug: 12. 5 Nm (1. 25 m·kgf, 9. 0 ft·lbf) EAU39842 Engine oil The engine oil level should be checked before each ride. In addition, the oil must be changed at the intervals specified in the periodic maintenance and lubrication chart. Place the motorcycle on a level surface and hold it in an upright position. A slight tilt to the side can result in a false reading. Start the engine, warm it up for several minutes, and then turn it off. Wait a few minutes until the oil settles, remove the oil filler cap, wipe the dipstick clean, insert it back into the oil filler hole (without screwing it in), and then remove it again to check the oil level. To install the spark plug 1. Measure the spark plug gap with a wire thickness gauge and, if necessary, adjust the gap to specification. TIP If a torque wrench is not available when installing a spark plug, a good estimate of the correct torque is 1/4­1/2 turn past finger tight. However, the spark plug should be tightened to the specified torque as soon as possible. Spark plug gap Spark plug gap: 0. 6­0. 7 mm (0. 024­0. 028 in) 6-8 PERIODIC MAINTENANCE AND ADJUSTMENT To change the engine oil 1. Start the engine, warm it up for several minutes, and then turn it off. [. . . ] 6-32 M Main switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1 Maintenance and lubrication, periodic. . . . . 6-4 Maintenance, emission control system . . . 6-3 Matte color, caution. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1 Model label. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-2 C Cables, checking and lubricating. . . . . . . . . . 6-22 Carburetor, adjusting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-13 Care. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1 Clutch free play, adjusting . . . . . . . . . . . . . . . . . . . . [. . . ]