User manual YAMAHA V STAR 1100 SILVERADO-2002

[. . . ] If you have any questions concerning the operation or maintenance of your motorcycle, please consult a Yamaha dealer. The design and manufacture of this Yamaha motorcycle fully comply with the emissions standards for clean air applicable at the date of manufacture. Yamaha has met these standards without reducing the performance or economy of operation of the motorcycle. To maintain these high standards, it is important that you and your Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. IMPORTANT MANUAL INFORMATION EAU10130 Particularly important information is distinguished in this manual by the following notations: The Safety Alert Symbol means ATTENTION! [. . . ] ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 18 * Shock absorber assembly Rear suspension link pivots Engine oil Engine oil filter element · Check operation and for oil leakage. · Apply lithium-soap-based grease lightly. · Change (warm engine before draining). · Check oil level and for oil leakage. · Change at initial 600 mi (1000 km) or 1 month, and thereafter every 16000 mi (25000 km) or 24 months. · Apply Yamaha chain and cable lube or engine oil SAE 10W-30 thoroughly. · Adjust the throttle cable free play if necessary. · Lubricate the throttle grip housing and cable. 19 * 20 21 * 22 Final gear oil Change. Change. 6 23 * Control cables 24 * Throttle grip housing and cable * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. NOTE: From 24000 mi (37000 km) or 36 months, repeat the maintenance intervals starting from 8000 mi (13000 km) or 12 months. 6-6 PERIODIC MAINTENANCE AND MINOR REPAIR EAU17630 NOTE: G The air filter needs more frequent service if you are riding in unusually wet or dusty areas. G Hydraulic brake service · After disassembling the brake master cylinders and calipers, always change the fluid. Regularly check the brake fluid levels and fill the reservoirs as required. · Every two years replace the internal components of the brake master cylinders and calipers, and change the brake fluid. Place the vehicle on a level surface and hold it in an upright position. NOTE: Make sure that the vehicle is positioned straight up when checking the oil level. A slight tilt to the side can result in a false reading. Start the engine, warm it up for several minutes, and then turn it off. Wait a few minutes until the oil settles, and then check the oil level through the check window located at the bottom-left side of the crankcase. This model is equipped with a canister to prevent the discharging of fuel vapor into the atmosphere. G Check each hose and canister for cracks or damage. G Make sure the vent hose is not blocked. Clean it if necessary. 6 6-10 PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: The engine oil should be between the minimum and maximum level marks. Remove the engine oil filler cap and drain bolt to drain the oil from the crankcase. NOTE: Check the washer for damage and replace it if necessary. Tightening torque: Engine oil drain bolt: 43 Nm (4. 3 m·kgf, 31 ft·lbf) 5. Add the specified amount of the recommended engine oil, and then install and tighten the oil filler cap. 1. [. . . ] 9-2 D Dimmer switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4 E Engine break-in. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-4 Engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-10 Engine, starting a warm . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]