User manual YAMAHA V-STAR XVS650AL

[. . . ] 2006 General manager of quality assurance div. representative name and signature MORIC CO. , LTD. 1450-6 Mori-machi Shuchi-gun Shizuoka 437-0292 JAPAN Telephone +81-538-85-0757 Facsimile +81-538-85-0456 URL:http://www. moric-jp. com INTRODUCTION EAU10100 Welcome to the Yamaha world of motorcycling!As the owner of the XJR1300, you are benefiting from Yamaha's vast experience and newest technology regarding the design and manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all advantages of your XJR1300. [. . . ] Owner's tool kit WARNING If you are not familiar with maintenance work, have a Yamaha dealer do it for you. The owner's tool kit is located under the seat. (See page 3-15. ) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor repairs. However, additional tools such as a torque wrench may be necessary to perform certain maintenance work correctly. NOTE: If you do not have the tools or experience required for a particular job, have a Yamaha dealer perform it for you. 6 6-1 PERIODIC MAINTENANCE AND MINOR REPAIR EAU17707 Periodic maintenance and lubrication chart NOTE: G The annual checks must be performed every year, except if a kilometer-based maintenance is performed instead. G From 50000 km, repeat the maintenance intervals starting from 10000 km. G Items marked with an asterisk should be performed by a Yamaha dealer as they require special tools, data and technical skills. ODOMETER READING (× 1000 km) NO. 1 * Fuel line 2 Spark plugs ITEM CHECK OR MAINTENANCE JOB 1 · Check fuel hoses for cracks or damage. 3 * Valves 4 Air filter element · Check valve clearance. · Check operation, fluid level and vehicle for fluid leakage. · Check operation, fluid level and vehicle for fluid leakage. · Check operation, fluid level and vehicle for fluid leakage. 10 20 30 40 ANNUAL CHECK Front and rear brake 25 * switches 26 Moving parts and cables Throttle grip housing and cable 27 * 28 * Air induction system 6 29 * 30 * Muffler and exhaust pipe Lights, signals and switches EAU36771 NOTE: G Air filter · This model's air filter is equipped with a disposable oil-coated paper element, which must not be cleaned with compressed air to avoid damaging it. · The air filter element needs to be replaced more frequently when riding in unusually wet or dusty areas. G Hydraulic brake and clutch service · Regularly check and, if necessary, correct the brake fluid and clutch fluid levels. 6-4 PERIODIC MAINTENANCE AND MINOR REPAIR · Every two years replace the internal components of the brake master cylinders and calipers as well as clutch master and release cylinders, and change the brake and clutch fluids. · Replace the brake and clutch hoses every four years and if cracked or damaged. 6 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18771 Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. 1. Place the panel in its original position, and then install the bolt. To remove one of the panels 1. Remove the bolt, and then pull the panel off as shown. 2. Install the seat. 6-6 PERIODIC MAINTENANCE AND MINOR REPAIR EAU19193 EAU19544 Panel C To remove the panel Remove the bolts, and then take the panel off. Checking the spark plugs The spark plugs are important engine components, which are easy to check. Since heat and deposits will cause any spark plug to slowly erode, the spark plugs should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plugs can reveal the condition of the engine. Bolt To install the panel Place the panel in the original position, and then install the bolts. To check the spark plugs 1. [. . . ] 3-14 Centerstand and sidestand, checking and lubricating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-23 Clutch lever. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-10, 6-15 I Identification numbers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-1 Ignition circuit cut-off system . . . . . . . . . . . . . . . . . 3-22 Immobilizer system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1 Immobilizer system indicator light . . . . . . . . . . . 3-4 Indicator and warning lights . . . . . . . . . . . . . . . . . . . . 3-4 K Key identification number. . . . . . . . . . . . . . . . . . . . . . . . 9-1 D Dimmer switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-9 Drive chain, cleaning and lubricating. . . . [. . . ]