User manual YAMAHA VINO 125-2007

[. . . ] ©YAMAHA OWNER'S MANUAL YJ125W LIT-11626-20-37 5YR-F8199-13 1 2 3 4 5 EAU10041 A WARNING 6 7 8 9 The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. AAHA LIT-CALIF-65-01 EAU10050 INTRODUCTION EAU10090 Congratulations on your purchase of the Yamaha VINO. This model is the result of Yamaha's vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. 1 This manual will give you an understanding of the operation, inspection, and basic maintenance of this scooter. [. . . ] Remove the engine oil filler cap and drain bolts to drain the oil from the crankcase. 1. 4. Engine oil drain bolt B O-ring Compression spring Strainer ZAUM00** 1. Engine oil drain bolt A ECA10410 c C 6. Check the O-ring for damage and replace it if necessary. Install the oil strainer, spring, O-ring and engine oil drain bolts, and then tighten the drain bolts to the specified torque. When removing the engine oil drain bolt, the O-ring, spring, and oil strainer will fall out. Take care not to lose these parts. 6-10 Final transmission oil<IXE> PERIODIC MAINTENANCE AND MINOR REPAIR Tightening torque: Engine oil drain bolt A: 23 Nm (2. 3 m»kgf, 16. 6 fHbf) Engine oil drain bolt B: 32 Nm (3. 2 m»kgf, 23. 1 fHbf) NOTE: Make sure that the O-ring is properly seated. Add the specified amount of the recommended engine oil, and then install and tighten the engine oil filler cap. Oil change quantity: 1. 00 L (1. 06 US qt) (0. 88 Imp. qt) ECA11670 8 Be sure no foreign material enters the crankcase. Start the engine, and then let it idle for several minutes while checking it for oil leakage. If oil is leaking, immediately turn the engine off and check for the cause. Turn the engine off, and then check the oil level and correct it if necessary. Install the panel. EAU20061 Final transmission oil The final transmission case must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the scooter. In addition, the final transmission oil must be changed as follows at the intervals specified in the periodic maintenance and lubrication chart. Start the engine, warm up the final transmission oil by riding the scooter for several minutes, and then stop the engine. Place an oil pan under the final transmission case to collect the used oil. Remove the oil filler cap and drain bolt to drain the oil from the final transmission case. 1 2 3 4 5 6 7 8 9 c C Do not use oils with a diesel specification of "CD" or oils of a higher quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. 6-11 Air filter and V-belt case air filter elements<IXE> PERIODIC MAINTENANCE AND MINOR REPAIR Tightening torque: Final transmission oil drain bolt: 23 Nm (2. 3 m»kgf, 16. 6 fHbf) 6. Add the specified amount of the recommended final transmission oil, and then install and tighten the oil filler cap. ZAUM00** EAUT1301 Air filter and V-belt case air filter elements The air filter and V-belt case air filter elements should be cleaned at the intervals specified in the periodic maintenance and lubrication chart. Clean both filter elements more frequently if you are riding in unusually wet or dusty areas. Remove the air filter case cover by removing the screw. 1. [. . . ] is designed and administered by Yamaha Motor Corporation to provide maximum owner satisfaction. You get uninterrupted factory-backed coverage for extra peace of mind. You choose the plan that's right for you: 12 months, 24 months, 36 months or, on certain models, even 48 months beyond your warranty period. is designed and administered by the same Yamaha people who handle your warranty - and it shows in the comprehensive coverage benefits. [. . . ]