User manual YAMAHA XJR1300-2007

[. . . ] OWNER'S MANUAL XJR1300 5WM-28199-E4 EAU26943 DECLARATION of CONFORMITY We Company: MORIC CO. , LTD. Address: 1450-6 Mori Mori-Machi Shuchi-gun Shizuoka 437-0292 Japan Hereby declare that the product: Kind of equipment: IMMOBILIZER Type-designation: 5SL-00 is in compliance with following norm(s) or documents: R&TTE Directive(1999/5/EC) EN300 330-2 v1. 1. 1(2001-6), EN60950-1(2001) Two or Three-Wheel Motor Vehicles Directive(97/24/EC: Chapter 8, EMC) Place of issue: Shizuoka, Japan Date of issue: 1 Aug. Contents To change contact person and integrate type-designation. 1 Version up the norm of EN60950 to EN60950-1 2 Date 9 Jun. [. . . ] Every 50000 km Every 1000 km and after washing the motorcycle or riding in the rain 13 Drive chain 14 * Steering bearings Every 20000 km 6 15 * Chassis fasteners 16 17 18 Brake and clutch lever pivot shafts Brake and shift pedal pivot shafts Sidestand, centerstand 19 * Sidestand switch 20 * Front fork 21 * Shock absorber assemblies 22 * Fuel injection system 6-3 PERIODIC MAINTENANCE AND MINOR REPAIR ODOMETER READING (× 1000 km) NO. ITEM CHECK OR MAINTENANCE JOB 1 23 24 Engine oil Engine oil filter element · Change. · Check oil level and vehicle for oil leakage. · Adjust the throttle cable free play if necessary. · Lubricate the throttle grip housing and cable. · Check the air cut-off valve, reed valve, and hose for damage. · Replace any damaged parts if necessary. · Check the screw clamp for looseness. 10 20 30 40 ANNUAL CHECK Front and rear brake 25 * switches 26 Moving parts and cables Throttle grip housing and cable 27 * 28 * Air induction system Muffler and exhaust pipe Lights, signals and switches 6 EAU36771 29 * 30 * NOTE: G Air filter · This model's air filter is equipped with a disposable oil-coated paper element, which must not be cleaned with compressed air to avoid damaging it. · The air filter element needs to be replaced more frequently when riding in unusually wet or dusty areas. G Hydraulic brake and clutch service · Regularly check and, if necessary, correct the brake fluid and clutch fluid levels. 6-4 PERIODIC MAINTENANCE AND MINOR REPAIR · Every two years replace the internal components of the brake master cylinders and calipers as well as clutch master and release cylinders, and change the brake and clutch fluids. · Replace the brake and clutch hoses every four years and if cracked or damaged. 6 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18771 Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. 1. Bolt Panels A and B To remove one of the panels 1. Remove the bolt, and then pull the panel off as shown. To install the panel 1. Place the panel in its original position, and then install the bolt. Install the seat. 6-6 PERIODIC MAINTENANCE AND MINOR REPAIR EAU19193 EAU19544 Panel C To remove the panel Remove the bolts, and then take the panel off. Checking the spark plugs The spark plugs are important engine components, which are easy to check. Since heat and deposits will cause any spark plug to slowly erode, the spark plugs should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plugs can reveal the condition of the engine. Bolt To install the panel Place the panel in the original position, and then install the bolts. To check the spark plugs 1. Check that the porcelain insulator around the center electrode on each spark plug is a medium-tolight tan (the ideal color when the vehicle is ridden normally). Check that all spark plugs installed in the engine have the same color. [. . . ] 3-4 EXUP system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-20 M Main switch/steering lock. . . . . . . . . . . . . . . . . . . . . . . . 3-2 Matte color, caution . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1 Model label . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]