User manual YAMAHA XT660-2004

[. . . ] OWNER'S MANUAL XT660R XT660X 5VK-F8199-E0 EAU26941 DECLARATION of CONFORMITY We Company: MORIC CO. , LTD. Address: 1450-6 Mori Mori-Machi Shuchi-gun Shizuoka 437-0292 Japan Hereby declare that the product: Kind of equipment: IMMOBILIZER Type-designation: 5SL-00, 5VS-00, 5VX-00, 3HT-00, 5UX-00, 5UX-10, 5KS-00 and 5KS-10 is in compliance with following norm(s) or documents: R&TTE Directive(1999/5/EC) EN300 330-2 v1. 1. 1(2001-6), EN60950(2000) Two or Three-Wheel Motor Vehicles Directive(97/24/EC: Chapter 8, EMC) Place of issue: Shizuoka, Japan Date of issue: Aug. 1st 2002 Kazuji Kawai representative name and signature INTRODUCTION EAU10100 Welcome to the Yamaha world of motorcycling!As the owner of the XT660R/XT660X, you are benefiting from Yamaha's vast experience and newest technology regarding the design and manufacture of high-quality products, which have earned Yamaha a reputation for dependability. [. . . ] Spark plug gap NOTE: If a torque wrench is not available when installing a spark plug, a good estimate of the correct torque is 1/4­1/2 turn past finger tight. However, the spark plug should be tightened to the specified torque as soon as possible. Install the spark plug cap. Spark plug gap: 0. 7­0. 8 mm (0. 028­0. 031 in) 2. Clean the surface of the spark plug gasket and its mating surface, and then wipe off any grime from the spark plug threads. 6-8 PERIODIC MAINTENANCE AND MINOR REPAIR EAUM1841 EWA10360 Engine oil and oil filter element The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter element replaced at the intervals specified in the periodic maintenance and lubrication chart. Place the vehicle on a level surface and hold it in an upright position. NOTE: Make sure that the vehicle is positioned straight up when checking the oil level. A slight tilt to the side can result in a false reading. Start the engine, warm it up for 10­ 15 minutes, and then turn it off. Wait a few minutes until the oil settles, remove the oil filler cap, wipe the dipstick clean, insert it back into the oil filler hole (without screwing it in), and then remove it again to check the oil level. NOTE: G The engine oil tank is located inside of the frame. G The engine oil should be between the minimum and maximum level marks. WARNING Never remove the engine oil tank cap after high-speed operation, otherwise hot engine oil could spout out and cause damage or injury. Always let the engine oil cool down sufficiently before removing the oil tank cap. If the engine oil is below the minimum level mark, add sufficient oil of the recommended type to raise it to the correct level. To change the engine oil (with or without oil filter element replacement) 1. Start the engine, warm it up for several minutes, and then turn it off. Install the engine oil drain attachment, provided with the owner's tool kit, under the drain bolt of the crankcase. Minimum level mark ECA10010 CAUTION: Do not operate the vehicle until you know that the engine oil level is sufficient. 6-9 PERIODIC MAINTENANCE AND MINOR REPAIR 1. Engine oil drain bolt (oil tank) 6 3. Place an oil pan under the engine to collect the used oil. Remove the engine oil filler cap and the drain bolt to drain the oil from the crankcase. Remove the drain bolt to drain the oil from the oil tank. 6. Remove the oil filter element drain bolt to drain the oil from the oil filter element. [. . . ] 3-4 Cowlings and panels, removing and installing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5 I Identification numbers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-1 Ignition circuit cut-off system . . . . . . . . . . . . . . . . . 3-15 Immobilizer system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1 Immobilizer system indicator light . . . . . . . . . . . 3-4 Indicator and warning lights . . . . . . . . . . . . . . . . . . . . 3-3 T Throttle cable free play, adjusting. . . . . . . . . 6-17 Throttle grip and cable, checking and lubricating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-25 Tires. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]