User manual YAMAHA XV535-2000

[. . . ] OWNER'S MANUAL XV535 3BT-28199-E6 INTRODUCTION EAU00001 Welcome to the Yamaha world of motorcycling! As the owner of a XV535, you are benefiting from Yamahas vast experience in and newest technology for the design and the manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all your XV535s advantages. The owners manual does not only instruct you in how to operate, inspect and maintain your motorcycle, but also in how to safeguard yourself and others from trouble and injury. In addition, the many tips given in this manual will help to keep your motorcycle in the best possible condition. [. . . ] It should be cleaned more frequently if you are riding in unusually wet or dusty areas. (See page 3-7 for seat removal and installation procedures. ) 2. Lift the front of the fuel tank upward and position it away from the air filter. (Do not remove the fuel tank. ) EW000071 l l Support the fuel tank carefully during this procedure. Do not tilt the fuel tank too much or pull it too hard because the fuel hose connections may become loose causing fuel leakage. 4. Remove the air filter case cover screw. 6-10 PERIODIC MAINTENANCE AND MINOR REPAIR 7. Reassemble by reversing the removal procedure. EC000082 CAUTION: l l 1. Air filter case cover Tab Holder Air filter 5. Slide the air filter case cover so as to unhook the tab on the rear of the cover from the holder on the frame. Then lift the air filter case cover upward without removing it. 6. Pull out the air filter element and tap it lightly to remove most of the dust and dirt. Blow out the remaining dirt with compressed air as shown. If the air filter element is damaged, replace it. Make sure the air filter is properly seated in the air filter case. The engine should never be run without the air filter installed. Excessive piston and/or cylinder wear may result. 6-11 PERIODIC MAINTENANCE AND MINOR REPAIR Carburetor adjustment EAU00630 1. Spacer EW000131 The carburetors are important parts of the engine and require very sophisticated adjustment. Most adjustments should be left to a Yamaha dealer who has the professional knowledge and experience to do so. However, the idle speed may be adjusted by the owner as part of routine maintenance. EC000095 CAUTION: The carburetors were set at the Yamaha factory after many tests. If they are changed, poor engine performance and damage may result. Make sure that the fuel hoses and vacuum hose are properly connected, in place and not pinched. If a hose is damaged, be sure to replace it. EC000086 CAUTION: When reinstalling the fuel tank holding bolts, make sure that the washers, damper rubbers and spacers are positioned properly. 6-12 PERIODIC MAINTENANCE AND MINOR REPAIR Idle speed adjustment EAU01168 NOTE: A diagnostic tachometer must be used for this procedure. Start the engine and warm it up for a few minutes at approximately 1, 000 to 2, 000 r/min. Occasionally rev the engine to 4, 000 to 5, 000 r/min. [. . . ] 6-5 Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1 Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2 Start switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3 Starter (choke) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]