User manual YAMAHA XVZ13ATM C

[. . . ] In addition, the many tips given in this manual will help keep your motorcycle in the best possible condition. If you have any further questions, do not hesitate to contact your Yamaha dealer. The Yamaha team wishes you many safe and pleasant rides. So, remember to put safety first! IMPORTANT MANUAL INFORMATION Particularly important information is distinguished in this manual by the following notations: The Safety Alert Symbol means ATTENTION! [. . . ] Dipstick NOTE: When adding oil, be careful not to overfill the engine; the oil level rises faster starting from the half level portion on the dipstick. @ @ 6. Insert the dipstick into the oil filler hole, and then tighten the oil filler cap. Install the rider seat. 6-9 PERIODIC MAINTENANCE AND MINOR REPAIR 1. Engine oil filter cartridge To change the engine oil (with or without oil filter cartridge replacement) 1. Start the engine, warm it up for several minutes, and then turn it off. Place an oil pan under the oil tank to collect the used oil. Remove the engine oil filler cap and drain bolt to drain the oil from the oil tank. NOTE: Skip steps 4­8 if the oil filter cartridge is not being replaced. @ @ 7. Apply a thin coat of engine oil to the O-ring of the new oil filter cartridge. NOTE: Make sure that the O-ring is properly seated. @ @ 4. Place an oil pan under the engine to correct the used oil. Remove the engine oil drain bolt to drain the oil from the crankcase. Tightening torque: Transfer case oil check bolt: 7. 5 Nm (0. 75 m·kg) To change the transfer case oil 1. Place an oil pan under the transfer case to collect the used oil. Remove the drain bolt and the check bolt to drain the oil from the transfer case. Install the drain bolt and the check bolt, and then tighten the drain bolt to the specified torque. Tightening torque: Transfer case oil drain bolt: 17. 5 Nm (1. 75 m·kg) 6 6-12 PERIODIC MAINTENANCE AND MINOR REPAIR 5. Start the engine and let it idle for several minutes while checking the transfer case for oil leakage. If oil is leaking, immediately turn the engine off and check for the cause. 1. Remove the oil filler cap, add the specified amount of the recommended transfer case oil, and then install and tighten the oil filler cap. 6 Recommended transfer case oil: See page 8-2. Air filter case EAU03707 Cleaning the air filter element The air filter element should be cleaned at the intervals specified in the periodic maintenance and lubrication chart. Clean the air filter element more frequently if you are riding in unusually wet or dusty areas. [. . . ] 3-13 High beam indicator light . . . . . . . . . . . . . . . . . . . . . . . . . 3-2 Horn switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6 R Rider seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12 C Carburetor, adjusting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-16 Care. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1 Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5 Clutch lever. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-7 Clutch lever free play, adjusting . . . . . . . . . . . . . 6-21 Conversion table. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5 S Safety information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Self-diagnosis device . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4 Shifting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-3 Shift pedal. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-7 Shift points (for Switzerland only) . . . . . . . . . . . . . 5-4 Shock absorber assembly, adjusting. . . . . . 3-14 Sidestand. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-15 Sidestand, checking and lubricating . . . . . . . 6-30 Spark plugs, checking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-7 Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1 Speedometer unit. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3 I Identification numbers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-1 Idling speed, adjusting . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]