User manual YAMAHA YZF-R1-2007

[. . . ] OWNER'S MANUAL YZF-R1 4C8-28199-E0 EAU26943 DECLARATION of CONFORMITY We Company: MORIC CO. , LTD. Address: 1450-6 Mori Mori-Machi Shuchi-gun Shizuoka 437-0292 Japan Hereby declare that the product: Kind of equipment: IMMOBILIZER Type-designation: 5SL-00 is in compliance with following norm(s) or documents: R&TTE Directive(1999/5/EC) EN300 330-2 v1. 1. 1(2001-6), EN60950-1(2001) Two or Three-Wheel Motor Vehicles Directive(97/24/EC: Chapter 8, EMC) Place of issue: Shizuoka, Japan Date of issue: 1 Aug. Contents To change contact person and integrate type-designation. 1 Version up the norm of EN60950 to EN60950-1 2 Date 9 Jun. [. . . ] ITEM CHECK OR MAINTENANCE JOB 1 24 25 Engine oil Engine oil filter cartridge · Change. · Check oil level and vehicle for oil leakage. · Check coolant level and vehicle for coolant leakage. · Adjust the throttle cable free play if necessary. · Lubricate the throttle grip housing and cable. · Check the air cut-off valve, reed valve, and hose for damage. · Replace any damaged parts if necessary. · Check the screw clamp for looseness. · Check operation, cable free play and pulley position. 10 20 30 40 ANNUAL CHECK 26 * Cooling system Front and rear brake 27 * switches 28 Moving parts and cables Throttle grip housing and cable Every 3 years 29 * 6 30 * Air induction system Muffler and exhaust pipe 31 * 32 * EXUP system Lights, signals and 33 * switches 6-4 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18680 NOTE: G Air filter · This model's air filter is equipped with a disposable oil-coated paper element, which must not be cleaned with compressed air to avoid damaging it. · The air filter element needs to be replaced more frequently when riding in unusually wet or dusty areas. G Hydraulic brake service · Regularly check and, if necessary, correct the brake fluid level. · Every two years replace the internal components of the brake master cylinders and calipers, and change the brake fluid. · Replace the brake hoses every four years and if cracked or damaged. 6 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18712 Removing and installing cowlings and panels The cowlings and panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a cowling or panel needs to be removed and installed. 1. Quick fastener screw Cowlings A and B 6 To remove one of the cowlings 1. Remove the quick fastener screws and the quick fasteners, slide the cowling backward, and then take it off. 1. 4. Panel A Panel C Cowling A Cowling C 1. Quick fastener 6-6 PERIODIC MAINTENANCE AND MINOR REPAIR 2. Fit the projections on the cowling into the slots and slide it forward. 1. Disconnect the turn signal light lead coupler. 1. Install the quick fasteners and the quick fastener screws. EAU42951 3. [. . . ] 6-26 Drive chain slack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-24 L License plate light bulb, replacing . . . . . . . . . 6-37 Luggage strap holders . . . . . . . . . . . . . . . . . . . . . . . . . . 3-25 E Engine break-in . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-3 Engine oil and oil filter cartridge . . . . . . . . . . . 6-10 Engine stop switch. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]