User manual YAMAHA YZF-600-2000

[. . . ] OWNER'S MANUAL YZF600R 4TV-28199-E4 EAU00001 INTRODUCTION Welcome to the Yamaha world of motorcycling!As the owner of a YZF600R, you are benefiting from Yamaha's vast experience in and newest technology for the design and the manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all your YZF600R's advantages. The owner's manual does not only instruct you in how to operate, inspect and maintain your motorcycle, but also in how to safeguard yourself and others from trouble and injury. [. . . ] Pour the recommended coolant into the radiator until it is full. 10. Remove the water pump drain bolt and drain the coolant. Remove the cylinder drain bolts and drain the coolant. CAUTION: Hard water or salt water is harmful to the engine. You may use soft water if you can't get distilled water. @ @ 6 15. Run the engine several minutes to recheck the coolant level in the radiator. If it is low, fill with more coolant until it reaches the top of the radiator. Check for coolant leakage. 6-14 PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: If you find any leaks, ask a Yamaha dealer to inspect. @ @ 6 18. Install the right air intake duct, then install and tighten the screw clamps. Install the fuel tank and fuel tank bolts. Install the coolant reservoir and bolts. Fill the coolant reservoir with the recommended coolant to the specified level. Air filter case cover EW000071 Air filter The air filter should be cleaned at the specified intervals. It should be cleaned more frequently if you are riding in unusually wet or dusty areas. Lift the fuel tank upward and position it away from the air filter case. (Do not remove the fuel hoses. ) @ q q WARNING Support the fuel tank carefully during this procedure. Do not tilt the fuel tank too much or pull it too hard because the fuel hose connections may become loose causing fuel leakage. @ 4. Remove the screws holding the air filter case cover. 6-15 PERIODIC MAINTENANCE AND MINOR REPAIR EC000082 @ CAUTION: q Make sure the air filter is properly seated in the air filter case. q The engine should never be run without the air filter installed. Excessive piston and/or cylinder wear may result. Reverse the removal procedures for installation. EW000131 @ 1. Remove the air filter from its guide and clean it with solvent. After cleaning, squeeze the air filter to remove the remaining solvent. 7. [. . . ] 3-8 Periodic maintenance and lubrication . . . . . . 6-2 Pre-operation check list . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1 R Rear brake pedal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-10 Rear brake pedal height adjustment . . . . . . [. . . ]